2021 Jeep GRAND CHEROKEE
Manufacturer communications & TSBs.Page 2

109157

NHTSA communication ID: 11026813

NHTSA source summary · Original PDF not reviewed by Recallfolio

ARMREST - REAR DOOR TRIM

Source components: SEATS.

S2521000005

NHTSA communication ID: 11026809

NHTSA source summary · Original PDF not reviewed by Recallfolio

The customer states the ABS and Traction Control warning comes on. Vehicle sets wheel speed BSCM/ABS fault codes.

Source components: POWER TRAIN · SERVICE BRAKES.

S2523000094

NHTSA communication ID: 11026641

NHTSA source summary · Original PDF not reviewed by Recallfolio

Power Liftgate Noise During Gate Operation

Source components: STRUCTURE:BODY.

08-396-25

NHTSA communication ID: 11026673

NHTSA source summary · Original PDF not reviewed by Recallfolio

Drivetrain Control Module (DTCM) Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● C1403 - 92 Transfer Case Range Position Sensor - Performance Or Incorrect Operation. ● U0403 - 00 Implausible Data Received From Transfer Case. Customers may experience the following: ● Service 4WD Light On in Instrument Panel Control (IPC) This bulletin involves replacing the DTCM.Drivetrain Control Module (DTCM) Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● C1403 - 92 Transfer Case Range Position Sensor - Performance Or Incorrect Operation. ● U0403 - 00 Implausible Data Received From Transfer Case. Customers may experience the following: ● Service 4WD Light On in Instrument Panel Control (IPC) This bulletin involves replacing the DTCM.

Source components: ELECTRICAL SYSTEM.

108974

NHTSA communication ID: 11026631

NHTSA source summary · Original PDF not reviewed by Recallfolio

THROTTLE BODY - NONE

Source components: ENGINE.

108942

NHTSA communication ID: 11026590

NHTSA source summary · Original PDF not reviewed by Recallfolio

MODULE - STEERING CONTROL

Source components: STEERING.

108941

NHTSA communication ID: 11026589

NHTSA source summary · Original PDF not reviewed by Recallfolio

MODULE - STEERING CONTROL

Source components: STEERING.

S2521000006

NHTSA communication ID: 11026560

NHTSA source summary · Original PDF not reviewed by Recallfolio

Service 4WD light on in the cluster. C14A1-74 DTC will be present (Active or Stored).

Source components: ELECTRICAL SYSTEM.

108833

NHTSA communication ID: 11026580

NHTSA source summary · Original PDF not reviewed by Recallfolio

AMPLIFIER - NONE

Source components: UNKNOWN OR OTHER.

108546

NHTSA communication ID: 11026565

NHTSA source summary · Original PDF not reviewed by Recallfolio

ISOLATOR - ENGINE MOUNT

Source components: ENGINE · STRUCTURE:BODY.

S258A000021

NHTSA communication ID: 11026552

NHTSA source summary · Original PDF not reviewed by Recallfolio

Diagnostic Trouble Code (DTC) B15A1-00 Media Port Connection 1 Connection Found Set.

Source components: ELECTRICAL SYSTEM.

108840

NHTSA communication ID: 11026571

NHTSA source summary · Original PDF not reviewed by Recallfolio

Hose- Oil Cooler Inlet, Outlet

Source components: ENGINE.

108547

NHTSA communication ID: 11026570

NHTSA source summary · Original PDF not reviewed by Recallfolio

ISOLATOR - ENGINE MOUNT

Source components: ENGINE · STRUCTURE:BODY.

S2423000012 REV.D

NHTSA communication ID: 11025734

NHTSA source summary · Original PDF not reviewed by Recallfolio

Power Liftgate Is Inoperative or Won’t Close.

Source components: STRUCTURE:BODY.

S2523000089

NHTSA communication ID: 11025733

NHTSA source summary · Original PDF not reviewed by Recallfolio

Passive Entry Exterior Door Handle Inoperative When Touched For Lock And Or Unlock.

Source components: ELECTRICAL SYSTEM · STRUCTURE:BODY.

S2523000065 REV.A

NHTSA communication ID: 11025735

NHTSA source summary · Original PDF not reviewed by Recallfolio

Diagnostic Trouble Code DTC(s) C1593-00, C2217-00, U0131-00. and Service Electric Power Steering Messages.

Source components: ELECTRICAL SYSTEM · STEERING.

S2521000004

NHTSA communication ID: 11025640

NHTSA source summary · Original PDF not reviewed by Recallfolio

The customer is experiencing a "clicking" noise during turns while driving on WL vehicles

Source components: POWER TRAIN.

S2509000009

NHTSA communication ID: 11025028

NHTSA source summary · Original PDF not reviewed by Recallfolio

Engine Oil Leak

Source components: ENGINE.

105646

NHTSA communication ID: 11024323

NHTSA source summary · Original PDF not reviewed by Recallfolio

MODULE - STEERING CONTROL & COLUMN

Source components: STEERING.

S2522000003

NHTSA communication ID: 11024311

NHTSA source summary · Original PDF not reviewed by Recallfolio

Tire Pressure Monitor (TPM) Warning Lamp On Or Flashing. Sensor(s) Not Reading And Or Showing Dashes.

Source components: WHEELS.

08-310-25

NHTSA communication ID: 11024060

NHTSA source summary · Original PDF not reviewed by Recallfolio

R1H Radio U33.43 USB Software Update Customers may experience one or more of the following: ● Unable to select the Turn by Turn Navigation. ● Blank Performance Pages (Rearview Camera (RVC) Functions Normally). ● Android Auto® Voice Recognition (VR) inoperative. ● Media tuner delayed. ● Charge Schedule not accepting updates via phone (RVC Functions Normally). ● Ambient light inoperative. ● Map in Instrument Panel Cluster (IPC) inoperative. ● Media Widget blank. ● Navigation map black. ● Off-Road Pages inoperative (RVC Functions Normally). ● VR inoperative. ● Incorrect song title displayed (Carplay® only). ● Radio display switches from Media Page to Home Page (RVC Functions Normally). ● Ghost touch on Navigation screen (RVC Functions Normally). ● Widgets missing. ● New User Profile does not load. ● Returns to wrong page after View Camera Event selected by customer in the Camera View Pages (RVC Functions Normally) This bulletin involves inspecting and if required, updating the radio software level to U33.43. Depending on the radio's current software level the radio may need a one or two USB update

Source components: ELECTRICAL SYSTEM.

08-302-25 REV. A

NHTSA communication ID: 11024049

NHTSA source summary · Original PDF not reviewed by Recallfolio

Not applicable to vehicles built for US market. Radio USB Update to U40.20 Customers may experience one or more of the following: ● Temperature displayed in the radio display screen and rear HVAC are mismatched. ● Auto door locks are inoperable. This bulletin involves inspecting and if required, updating the radio software level to U40.20. Depending on the radio’s current software level the radio may need a one or two USB update.

Source components: ELECTRICAL SYSTEM.

08-266-25 REV. A

NHTSA communication ID: 11023582

NHTSA source summary · Original PDF not reviewed by Recallfolio

Not applicable to vehicles built for US market. R1H Radio U40.20 USB Software Update - Korea Customers may experience one or more of the following: ● **T-maps navigation feature is intermittently not available due to map loading. ● When the navigation speed alarm margin is set and the while driving the vehicle between the speed limit and the set margin, the navigation speed alarm will sound off continuously and the user is unable to control the volume. ● After setting a navigation destination and then the customer is following the navigation route, the navigation system will stop operating. ● Navigation touch screen menu is inoperable after setting a navigation destination. The home screen widget will be black and the navigation display map will no longer show the navigation route.** ● WI-FI Software update pop up is being triggered in non connected vehicles. ● Vehicle Forward Collision Warning must have two options: OFF/ Warning + Active Braking. ● Temperature shows at upper left and right of center display highlights opposite side of what temperature hard switch is pressed. Affects RHD only. ● With key on and radio on, The radio display freezes then restarts (Rearview Camera (RVC) functions normally). ● Radio is taking more than one minute to start after starting the engine (RVC functions normally). ● System displays a blank screen in E-Hybrid tab when user switches into dark-theme mode (RVC functions normally). This bulletin involves inspecting and if required, updating the radio software level to **U40.20**. Depending on the radio's current software level the radio may need a one or two USB update

Source components: ELECTRICAL SYSTEM.

08-237-25 REV. A

NHTSA communication ID: 11023581

NHTSA source summary · Original PDF not reviewed by Recallfolio

Not applicable to vehicles built for US market. R1H Radio U40.20 USB Software Update Customers may experience one or more of the following: ● **Temperature displayed in the radio display and rear HVAC are mismatched.** ● Wi-fi Software update pop-up is being triggered in non connected vehicles. ● Radio freezes and then restarts. ● Head Unit (HU) freezes and then restarts. ● HU is taking more than one minute to start after starting the engine. ● System displays blank screen in E-Hybrid tab when user switched to dark theme mode. Rearview Camera (RVC) functions normally. This bulletin involves inspecting and if required, updating the radio software level to **U40.20**. Depending on the radio’s current software level the radio may need a one or two step USB update

Source components: ELECTRICAL SYSTEM.

9100670

NHTSA communication ID: 11023618

NHTSA source summary · Original PDF not reviewed by Recallfolio

Data collection required for all 2020-2026MY vehicles with 3.6L PSU engines during any of their first 3 engine oil changes. This data collection is applicable to all vehicle with engines with sales codes: ERG, ERC, EH3 and ERF. To assist with monitoring and quality improvement of the 3.6L engine, every time a vehicle comes for any of the first 3 oil changes, please use wiTECH to record the total engine idle time and the total engine runtime. 1. Prior to perform the oil change connect wiTECH diagnostic tool. 2. Navigate to the topology screen on the action item section. 3. Once the topology screen loads, disconnect wiTECH and continue with oil change.

Source components: ENGINE.

08-317-25

NHTSA communication ID: 11023589

NHTSA source summary · Original PDF not reviewed by Recallfolio

Flash: Amplifier (AMP) Diagnostic and System Updates **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● B143B-12 - ANC Microphone 1-Circuit Short To Battery. ● B143C-12 - ANC Microphone 2-Circuit Short To Battery. ● B143E-12 - ANC Microphone 3-Circuit Short To Battery. ● B143F-12 - ANC Microphone 4-Circuit Short To Battery. NOTE: The DTCs are wrongly set and do not affect Active Noise Cancellation (ANC) performance. This bulletin involves updating the AMP with the latest available software

Source components: ELECTRICAL SYSTEM.

08-313-25

NHTSA communication ID: 11023585

NHTSA source summary · Original PDF not reviewed by Recallfolio

Flash: Amplifier (AMP) Diagnostic and System Updates Customers may experience one or more of the following: ● **Droning noises coming out of the speakers at specific RPMs that range from 1200 to 1800 RPM. Probability of occurence is most likely during cold ambient temperatures.** ● High pitched noise at start up or idle under cold conditions. This bulletin involves updating the AMP with the latest available software.

Source components: ELECTRICAL SYSTEM.

S2519000008 REV.A

NHTSA communication ID: 11023620

NHTSA source summary · Original PDF not reviewed by Recallfolio

Noise From Front End While Steering Or Turning The Steering Wheel.

Source components: UNKNOWN OR OTHER.

S2523000079

NHTSA communication ID: 11023619

NHTSA source summary · Original PDF not reviewed by Recallfolio

Rear Door Mounted Window Switch Button Is Inoperative, Stuck, Or Switch Button Does Not Return To Original Position After Pushed.

Source components: STRUCTURE:BODY.

9100671

NHTSA communication ID: 11023329

NHTSA source summary · Original PDF not reviewed by Recallfolio

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order "68" part number for New unsold units only.

Source components: ELECTRICAL SYSTEM.

23-008-25 REV. A

NHTSA communication ID: 11023326

NHTSA source summary · Original PDF not reviewed by Recallfolio

Exterior Front Lamps Condensation Clearing Procedure *Some customers may report that on occasion vehicle exterior front lamps (headlamps, fog lamps, grille lamps, logo lamps or signature lamps) assemblies are fogged with a light layer of condensation on the inside of the lenses*

Source components: STRUCTURE:BODY.

02-002-25 REV. A

NHTSA communication ID: 11023168

NHTSA source summary · Original PDF not reviewed by Recallfolio

Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.

Source components: SUSPENSION.

106357

NHTSA communication ID: 11023076

NHTSA source summary · Original PDF not reviewed by Recallfolio

CENTER STACK - DISPLAY

Source components: ELECTRICAL SYSTEM.

106345

NHTSA communication ID: 11023073

NHTSA source summary · Original PDF not reviewed by Recallfolio

SHAFT - STEERING COLUMN INTERMEDIATE

Source components: STEERING.

106346

NHTSA communication ID: 11023072

NHTSA source summary · Original PDF not reviewed by Recallfolio

SHAFT - STEERING COLUMN INTERMEDIATE

Source components: STEERING.

14-004-25 REV. B

NHTSA communication ID: 11022173

NHTSA source summary · Original PDF not reviewed by Recallfolio

Extended Crank Condition Due To Loss of Fuel Pressure Customers may experience the following: ● Extended engine crank condition. This bulletin involves performing a fuel pressure test and possibly replacing the **fuel pressure regulator**.

Source components: FUEL/PROPULSION SYSTEM.

08-266-25

NHTSA communication ID: 11022009

NHTSA source summary · Original PDF not reviewed by Recallfolio

Not applicable to vehicles built for US market. R1H Radio U33.43 USB Software Update Customers may comment on one or more of the following: ● WI-FI Software update pop up is being triggered in non connected vehicles. ● Vehicle Forward Collision Warning must have two options: OFF/ Warning + Active Braking. ● Temperature shows at upper left and right of center display highlights opposite side of what temperature hard switch is pressed. Affects RHD only. ● With key on and radio on, The radio display freezes then restarts. ● Radio is taking more than one minute to start after starting the engine. ● System displays a blank screen in E-Hybrid tab when user switches into dark-theme mode This bulletin involves inspecting and if required, updating the radio software level to U33.43. Depending on the radio’s current software level the radio may need a one or two step USB update

Source components: ELECTRICAL SYSTEM.

9100645

NHTSA communication ID: 11022026

NHTSA source summary · Original PDF not reviewed by Recallfolio

Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.

Source components: UNKNOWN OR OTHER.

31-001-25 REV. A

NHTSA communication ID: 11022012

NHTSA source summary · Original PDF not reviewed by Recallfolio

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

Source components: STRUCTURE:BODY.

31-001-25

NHTSA communication ID: 11022003

NHTSA source summary · Original PDF not reviewed by Recallfolio

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates

Source components: STRUCTURE:BODY.

S2223000074 REV.B

NHTSA communication ID: 11021852

NHTSA source summary · Original PDF not reviewed by Recallfolio

Power Side Steps Reverse, Stop In Motion, Do Not Deploy Or Stow, And May Have a Chirp Noise.

Source components: ELECTRICAL SYSTEM · STRUCTURE:BODY.

S2408000079 REV.A

NHTSA communication ID: 11021853

NHTSA source summary · Original PDF not reviewed by Recallfolio

Liftgate Lock Button Inoperative, Cluster Message “Service Keyless System”

Source components: ELECTRICAL SYSTEM.

9100639

NHTSA communication ID: 11021845

NHTSA source summary · Original PDF not reviewed by Recallfolio

Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.

Source components: ENGINE.

S2108000236 REV.B

NHTSA communication ID: 11021846

NHTSA source summary · Original PDF not reviewed by Recallfolio

Windshield HUD (Head Up Display) Display Features

Source components: ELECTRICAL SYSTEM · FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL.

08-237-25

NHTSA communication ID: 11021823

NHTSA source summary · Original PDF not reviewed by Recallfolio

Not applicable to vehicles built for US market. R1H Radio U33.43 USB Software Update Customers may experience one or more of the following: ● Wi-fi Software update pop-up is being triggered in non connected vehicles. ● Radio freezes and then restarts. ● Head Unit (HU) freezes and then restarts. ● HU is taking more than one minute to start after starting the engine. ● System displays blank screen in E-Hybrid tab when user switched to dark theme mode. This bulletin involves inspecting and if required, updating the radio software level to U33.43. Depending on the radio’s current software level the radio may need a one or two step USB update.

Source components: ELECTRICAL SYSTEM.

S258A000017

NHTSA communication ID: 11021581

NHTSA source summary · Original PDF not reviewed by Recallfolio

Door speaker Inoperative or No Sound

Source components: ELECTRICAL SYSTEM.

S2509000001 REV.B

NHTSA communication ID: 11021043

NHTSA source summary · Original PDF not reviewed by Recallfolio

Engine Rattle Noise

Source components: ENGINE.

106320

NHTSA communication ID: 11021047

NHTSA source summary · Original PDF not reviewed by Recallfolio

Warranty Newsletter – Volume 11, Issue 7

Campaign / software reference: Vol 11 Issue 7

Source components: UNKNOWN OR OTHER.

106321

NHTSA communication ID: 11021046

NHTSA source summary · Original PDF not reviewed by Recallfolio

FCA Caribbean Warranty Newsletter – Volume 11, Issue 7

Campaign / software reference: Vol 11 Issue 7

Source components: UNKNOWN OR OTHER.

S2422000001 REV.D

NHTSA communication ID: 11021039

NHTSA source summary · Original PDF not reviewed by Recallfolio

Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.

Source components: ELECTRICAL SYSTEM.

08-220-25

NHTSA communication ID: 11021010

NHTSA source summary · Original PDF not reviewed by Recallfolio

Rear Taillamp Condensation Clearing Procedure On occasion, vehicle exterior taillamp assemblies are fogged with a light layer of condensation on the inside of the lenses Fig. 1. This may be reported after the lamps have been turned on and brought up to operating temperature, turned off and then rapidly cooled by cold water (such as rain, or the water from a vehicle wash). Lens fogging can also occur under certain atmospheric conditions after a vehicle has been parked outside overnight (i.e. a warm humid day followed by clear cool night). This will usually clear as atmospheric conditions change to allow the condensation to change back into a vapor. Turning the taillamps on will usually accelerate this process. This bulletin is to communicate the procedure for rear taillamp condensation clearing.

Source components: STRUCTURE:BODY.

S2523000061 REV.A

NHTSA communication ID: 11020853

NHTSA source summary · Original PDF not reviewed by Recallfolio

Blind Spot Mirror Warning Inoperative Or Intermittently Inoperative. Service Blind Spot Message In Cluster.

Source components: STRUCTURE:BODY.

09-018-25

NHTSA communication ID: 11020832

NHTSA source summary · Original PDF not reviewed by Recallfolio

Engine Cylinder Block Porosity Inspection - Engine Cold Start Rough Idle Customers may experience the following: ● Rough engine idle when cold starting the engine. ● Low coolant level in coolant recovery bottle.

Source components: ENGINE.

105648

NHTSA communication ID: 11020858

NHTSA source summary · Original PDF not reviewed by Recallfolio

MODULE - ENGINE CONTROLLER

Source components: ENGINE.

9100627

NHTSA communication ID: 11020855

NHTSA source summary · Original PDF not reviewed by Recallfolio

To inform dealers about the 850RE valve body PN: R8348504A connector: the original 16-pin connector included six pins that were not used in this application. To simplify the design, the connector has been optimized and updated to a 10-pin configuration.

Source components: POWER TRAIN.

S2519000006

NHTSA communication ID: 11020847

NHTSA source summary · Original PDF not reviewed by Recallfolio

Steering Repair Information Involving Toe Angle. Tie Rod And Or Electric Power Steering (EPS) Units.

Source components: ELECTRICAL SYSTEM · STEERING.

21-009-25 REV. C

NHTSA communication ID: 11020636

NHTSA source summary · Original PDF not reviewed by Recallfolio

850RE D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear This bulletin involves replacing the D clutch.

Source components: POWER TRAIN.

S2208000138 REV.B

NHTSA communication ID: 11020600

NHTSA source summary · Original PDF not reviewed by Recallfolio

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

Source components: ELECTRICAL SYSTEM.

S2523000065

NHTSA communication ID: 11020597

NHTSA source summary · Original PDF not reviewed by Recallfolio

Diagnostic Trouble Code DTC(s) C1593-00, C2217-00, U0131-00. and Service Electric Power Steering Messages.

Source components: ELECTRICAL SYSTEM · STEERING.

S2219000005 REV.D

NHTSA communication ID: 11020596

NHTSA source summary · Original PDF not reviewed by Recallfolio

Check Engine Lamp On. Warning Messages in the Cluster. U0131 Lost Communication with Power Steering Control Module Set.

Source components: ELECTRICAL SYSTEM · STEERING.

9100622

NHTSA communication ID: 11020608

NHTSA source summary · Original PDF not reviewed by Recallfolio

When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order the roller-finger followers (rocker arms) separately, as these are included in the camshaft parts kit.

Source components: ENGINE.

9100618

NHTSA communication ID: 11020265

NHTSA source summary · Original PDF not reviewed by Recallfolio

Display Verify Z part number availability. Order a Z part number for all Exchange Orders: Warranty, Mopar, customer pay and service contract. Order regular part number for New unsold units only.

Source components: ELECTRICAL SYSTEM.

S2523000061

NHTSA communication ID: 11019761

NHTSA source summary · Original PDF not reviewed by Recallfolio

Blind Spot Mirror Warning Inoperative Or Intermittently Inoperative. Service Blind Spot Message In Cluster.

Source components: STRUCTURE:BODY.

9100614

NHTSA communication ID: 11019773

NHTSA source summary · Original PDF not reviewed by Recallfolio

ADJUSTER Valve Lash Customer's complaint may include a ticking noise coming from the engine. Technician's observations can refer to spongy or stuck hydraulic lash adjusters. Exhaust lash adjusters found with a "spongy" condition (compressible plunger) leading to the assumption of being defective/malfunctioning. EXHAUST lash adjusters are designed to be COMPRESSIBLE by hand. Intake lash adjusters found with a stiff or stuck condition (non-compressible plunger) leading to the assumption of being defective/malfunctioning. INTAKE lash adjusters are designed to be NON COMPRESSIBLE by hand. Do Not Replace EXHAUST lash adjusters when the following condition is present: should be compressible, but they will exert a reactionary spring force during compression and return to full expansion without a compression force. Do Not Replace INTAKE lash adjusters when the following condition is present: should feel very firm and difficult to compress. Once the correct functioning of the intake and exhaust lash adjusters is validated with the procedure above, refer to the Service Manual "HYDRAULIC LIFTER(S) NOISE DIAGNOSIS" procedure. After the corresponding service procedures from the Service Manual involving the Lash Adjusters have been conducted, refer to the detailed instructions in the Service Manual to diagnose and/or service any other component.

Source components: ENGINE.

09-015-25

NHTSA communication ID: 11019618

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Spark Knock/Engine Symptoms Customers may experience the following: ● Knocking or pinging noise coming from the engine upon acceleration. This bulletin involves cleaning the piston heads and cylinder head combustion chambers to resolve a spark knock condition being caused by oil intrusion through the PCV system."

Source components: ENGINE.

105590

NHTSA communication ID: 11019600

NHTSA source summary · Original PDF not reviewed by Recallfolio

Warranty Newsletter – Volume 11, Issue 6

Source components: UNKNOWN OR OTHER.

105591

NHTSA communication ID: 11019598

NHTSA source summary · Original PDF not reviewed by Recallfolio

FCA Caribbean Warranty Newsletter – Volume 11, Issue 6

Source components: UNKNOWN OR OTHER.

S2523000054

NHTSA communication ID: 11019450

NHTSA source summary · Original PDF not reviewed by Recallfolio

Intermittent Vibration Buzz Squeak Rattle (BSR) Shaking Felt In Steering Wheel.

Source components: LANE DEPARTURE: ASSIST · LANE DEPARTURE: WARNING · STEERING.

08-179-25

NHTSA communication ID: 11018869

NHTSA source summary · Original PDF not reviewed by Recallfolio

"12 Channel Amplifier Popping Noise Sound Customers may experience the following: ● Popping sound coming from the speakers during engine start/run. This bulletin involves replacing the Audio Amplifier."

Source components: ELECTRICAL SYSTEM.

S2519000004REVA

NHTSA communication ID: 11018614

NHTSA source summary · Original PDF not reviewed by Recallfolio

Steering Wheel Off Center. Customer Complaint/Technician Observation: Customer may state the vehicle drives straight but the steering wheel is off center. They may also describe the condition as a pull or a lead due to them trying to keep the steering wheel centered. Discussion: Drive on both highway and city roads if possible. If equipped with air suspension, place the vehicle in normal ride height (NRH). Refer to Service Library 02 - Front Suspension / Wheel Alignment / Diagnosis and Testing for a list of conditions, possible causes and corrections.

Source components: STEERING.

S2519000004

NHTSA communication ID: 11018598

NHTSA source summary · Original PDF not reviewed by Recallfolio

Steering Wheel Off Center. Customer Complaint/Technician Observation: Customer may state the vehicle drives straight but the steering wheel is off center. They may also describe the condition as a pull or a lead due to them trying to keep the steering wheel centered. Discussion: Drive on both highway and city roads if possible. If equipped with air suspension, place the vehicle in normal ride height (NRH). Refer to Service Library 02 - Front Suspension / Wheel Alignment / Diagnosis and Testing for a list of conditions, possible causes and corrections.

Source components: STEERING.

9100595

NHTSA communication ID: 11018646

NHTSA source summary · Original PDF not reviewed by Recallfolio

Front Door Interior Panels: Warped Interior Door Panel / Broken Panel / Door Panel Not Fully Seated Observation: Would observe that the interior door panel is not properly seated or attached. Panel(s) may appear warped or out of position in some areas. No signs of damage should be expected. How to diagnose: Visually inspect the door panel(s) for proper installation and check for the presence of broken or loose clips. Remove the panel and inspect clips and clip towers. Next step would be reinstalling the panel if visual inspection does not find any issues. Repair Procedure: Require a picture of the door panel(s) in the 'as found' condition so we can understand what warped means in the claims that are being created. After, check the door panel for proper installation and for the presence of broken or loose clips. Remove the panel, following normal servicing procedure, and inspect clips and clip towers. If any clips are broken or missing, replace prior to reinstalling original door. After confirmation that no loose/broken/damaged clips and/or clip towers, and reinstalling door panels does not correct issue, then a 'front door trim panel' kit / claim would be acceptable. In this case, Stellantis would like to request the panel back. How to validate fix: Verify that door has no loose/broken/damaged clips and/or clip towers. Replace any broken/missing clips where possible. Then validate that reinstalling the interior door panel addresses initial issue made within the claim.

Source components: STRUCTURE:BODY.

9100594

NHTSA communication ID: 11018640

NHTSA source summary · Original PDF not reviewed by Recallfolio

Front Door Interior Panels: Warped Interior Door Panel / Broken Panel / Door Panel Not Fully Seated Observation: Would observe that the interior door panel is not properly seated or attached. Panel(s) may appear warped or out of position in some areas. No signs of damage should be expected. How to diagnose: Visually inspect the door panel(s) for proper installation and check for the presence of broken or loose clips. Remove the panel and inspect clips and clip towers. Next step would be reinstalling the panel if visual inspection does not find any issues. Repair Procedure: Require a picture of the door panel(s) in the 'as found' condition so we can understand what warped means in the claims that are being created. After, check the door panel for proper installation and for the presence of broken or loose clips. Remove the panel, following normal servicing procedure, and inspect clips and clip towers. If any clips are broken or missing, replace prior to reinstalling original door. After confirmation that no loose/broken/damaged clips and/or clip towers, and reinstalling door panels does not correct issue, then a 'front door trim panel' kit / claim would be acceptable. In this case, Stellantis would like to request the panel back. How to validate fix: Verify that door has no loose/broken/damaged clips and/or clip towers. Replace any broken/missing clips where possible. Then validate that reinstalling the interior door panel addresses initial issue made within the claim.

Source components: STRUCTURE:BODY.

02-002-25

NHTSA communication ID: 11018676

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts. "

Source components: SUSPENSION.

09-011-25

NHTSA communication ID: 11018482

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Misfire Diagnostic Trouble Codes (DTCs), Rough Idle, Valvetrain Noise Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P0305 - Cylinder 5 Misfire. ● P0306 - Cylinder 6 Misfire. Customers may comment on one or more of the following: ● Rough idle. ● Valvetrain noise. "

Source components: ENGINE.

S2519000003

NHTSA communication ID: 11018448

NHTSA source summary · Original PDF not reviewed by Recallfolio

Slight Pull, Drift, Wander. Lack Of Precise Steering.

Source components: STEERING.

S2323000002 REV.A

NHTSA communication ID: 11018447

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Washer Light On And Will Not Turn Off After Adding Washer Solvent."

Source components: ELECTRICAL SYSTEM.

105038

NHTSA communication ID: 11018500

NHTSA source summary · Original PDF not reviewed by Recallfolio

TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE

Source components: FUEL/PROPULSION SYSTEM.

104686

NHTSA communication ID: 11018410

NHTSA source summary · Original PDF not reviewed by Recallfolio

BOLT - HEX FLANGE HEAD

Source components: UNKNOWN OR OTHER.

105039

NHTSA communication ID: 11018408

NHTSA source summary · Original PDF not reviewed by Recallfolio

TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE

Source components: FUEL/PROPULSION SYSTEM.

08-105-25 REV. A

NHTSA communication ID: 11018465

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Flash: Trailer Tow Module (TTM) Updates Customers may comment on one or more of the following: ● If the vehicle is traveling at less than 5 kph (3 mph) and the brake pedal is pressed, then both turn lights will flash for two milliseconds. ● If the vehicle is traveling at less than 5 kph (3 mph) and one turn light is activated, then the opposite turn light will flash for 20 milliseconds. NOTE: This issue only effects the trailer lighting This bulletin involves updating the TTM with the latest available software."

Source components: ELECTRICAL SYSTEM.

9100570

NHTSA communication ID: 11018453

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Transmission Fluid Please note fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Visible ""glitter"" or debris in the pan does not justify complete unit replacements."

Source components: POWER TRAIN.

9100534 Rev 1

NHTSA communication ID: 11018452

NHTSA source summary · Original PDF not reviewed by Recallfolio

Transmission "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, visible ""glitter"" or debris in the pan and fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback."

Source components: POWER TRAIN.

9100498 Rev 3

NHTSA communication ID: 11018451

NHTSA source summary · Original PDF not reviewed by Recallfolio

3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. Refer to SOL # S2509000004. It is also important to confirm that the vehicle being repaired has the latest calibration/software update for oil pump operation mode (high pressure mode) during engine start up. RU, VF, WL & WD vehicles already include the latest oil pump mode in all 25MY and beyond. 24MY service releases are also available. JL & JT were updated as a running change in 24MY and beyond (08/15/24 & 08/19/24 respectively). 24MY service releases available. DT was updated starting 25MY and beyond. If the vehicle to be repaired is a 24MY vehicle with a service release available, please follow the released service procedures to update to the corresponding calibration/software.

Source components: ENGINE.

S2523000046

NHTSA communication ID: 11018278

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Check Engine Lamp On. Diagnostic Trouble Code (DTC) P1D73 And Or P05AE For Active Grill Shutter (AGS)."

Source components: ELECTRICAL SYSTEM.

104683

NHTSA communication ID: 11018240

NHTSA source summary · Original PDF not reviewed by Recallfolio

CARPET - REAR FLOOR

Source components: STRUCTURE:BODY.

S2523000040

NHTSA communication ID: 11017877

NHTSA source summary · Original PDF not reviewed by Recallfolio

Center Console Armrest Lid Does Not Stay Open, Feels Loose, Does Not Latch.

Source components: STRUCTURE:BODY.

S2523000036

NHTSA communication ID: 11017403

NHTSA source summary · Original PDF not reviewed by Recallfolio

Sunroof Inoperative, Not Moving To Open Or Closed Positions.

Source components: ELECTRICAL SYSTEM · STRUCTURE:BODY.

S2108000241 REV.B

NHTSA communication ID: 11017400

NHTSA source summary · Original PDF not reviewed by Recallfolio

No Crank, No Start, Start Stop Inoperative

Source components: ENGINE.

S2523000034

NHTSA communication ID: 11017233

NHTSA source summary · Original PDF not reviewed by Recallfolio

C008E-00 Setting After Windshield Replacement

Source components: FORWARD COLLISION AVOIDANCE: WARNINGS · STRUCTURE:BODY.

9100546

NHTSA communication ID: 11017069

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Display Verify Z part number availability. Order a Z part number for all Exchange Orders: warranty, Mopar, customer pay and service contract. Order regular part number for New unsold units only."

Source components: ELECTRICAL SYSTEM.

104558

NHTSA communication ID: 11016951

NHTSA source summary · Original PDF not reviewed by Recallfolio

FCA Caribbean Warranty Newsletter – Volume 11, Issue 4

Source components: UNKNOWN OR OTHER.

104557

NHTSA communication ID: 11016939

NHTSA source summary · Original PDF not reviewed by Recallfolio

Warranty Newsletter – Volume 11, Issue 4

Source components: UNKNOWN OR OTHER.

08-105-25

NHTSA communication ID: 11017060

NHTSA source summary · Original PDF not reviewed by Recallfolio

"Flash: Trailer Tow Module(TTM) Updates Customers may comment on one or more of the following: ● If the vehicle is traveling at less than 5 kph (3 mph) and the brake pedal is pressed, then both turn lights will flash for two milliseconds. ● If the vehicle is traveling at less than 5 kph (3 mph) and one turn light is activated, then the opposite turn light will flash for 20 milliseconds This bulletin involves updating the TTM with the latest available software."

Source components: ELECTRICAL SYSTEM.

21-009-25 REV. B

NHTSA communication ID: 11016879

NHTSA source summary · Original PDF not reviewed by Recallfolio

"850RE D Clutch Repair **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear This bulletin involves replacing the D clutch."

Source components: POWER TRAIN.

S2523000023

NHTSA communication ID: 11016708

NHTSA source summary · Original PDF not reviewed by Recallfolio

Trailer Tow Lights Inoperative. Diagnostic Trouble Codes (DTCs) B166E-13 B17AD-13 May Be Set.

Source components: ELECTRICAL SYSTEM.

S2509000004

NHTSA communication ID: 11016439

NHTSA source summary · Original PDF not reviewed by Recallfolio

Misfire DTCs, Rough Idle, Valvetrain Noise

Source components: ENGINE.

S2523000010 REV.A

NHTSA communication ID: 11016424

NHTSA source summary · Original PDF not reviewed by Recallfolio

Exterior Rear View Mirror Stained And Will Not Clean.

Source components: STRUCTURE:BODY.

S2509000001 REV.A

NHTSA communication ID: 11016107

NHTSA source summary · Original PDF not reviewed by Recallfolio

Engine Rattle Noise

Source components: ENGINE.

S258A000011

NHTSA communication ID: 11016105

NHTSA source summary · Original PDF not reviewed by Recallfolio

Crackle, Pop or Growl noise At Start-up

Source components: UNKNOWN OR OTHER.