Original record summaries, dates and identifiers for this model-year. Records 601–698 of 698, ordered newest first. Dated records on this page: Mar 24, 2016–Jan 19, 2017.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Jan 19, 2017Service Bulletin/Repair Instructions
TJ32183.1.2-2017
NHTSA communication ID: 10167863
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Service Action S89807 Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 vehicles. Volvo has identified the painted surface under the exterior door handles may become scratched by the handles. The corrective action is add tape under all four (4) exterior door handles
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Low Battery Message, Engine Remote Start inop, flat 12V battery Service: The most recent VCM software release can cause any or all of the above symptoms. *The current solution is to install VCM repair software by following the procedure below: 1. Perform a Total Upgrade according to TJ 31543 to bring all vehicle nodes to the latest software status. The Upgrades list in VIDA should be empty before proceeding. *2. Download the appropriate SP below to prevent the above symptoms and re-enable ERS XC90: SP 31676890, CMQ VCM Fix S90: SP 31676891, CMQ VCM Fix 3. Drive the vehicle over 20mph to release the VCM from diagnostic mode. ERS will be unavailable until this is done. 4. Close and lock the vehicle for 3+ minutes to allow the network to shut down before testing ERS. PLEASE NOTE - DO NOT perform a Total Upgrade or VCM Upgrade after performing this procedure (they will now appear in the Upgrades list). Doing so will re-install the affected software. - Not all battery drains are caused by this issue. *The repair software will be integrated with regular VCM Upgrade/Reload and Total Upgrade/PDS/Service 2.0 packages in the coming weeks *This TJ will be updated when the updated software packages are available.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Service Manager Bulletin: The online bookstore, www.volvotechinfo.com, serves Volvo Retailers, employees, Independent Repairers and customers throughout the United States and Canada by providing easy order-access to service, parts and owners? literature over the Internet.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Climate system, high fan speed noise. Customer may experience a high fan speed noise regardless of the fan speed selection. This may be due to accidentally touching the 2nd row display. A new logic in the CCM software was implemented 2016w46, that allows rear climate display to start in default mode 72/72 Auto with fan level 2. This will take place after every restart of engine. Service: Perform Total Upgrade according to TJ-31543.
NHTSA source summary · Original PDF not reviewed by Recallfolio
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Improved low fuel indication A more detailed low fuel indication can be added in the DIM (Driver Information Module). A text message which the driver has to actively acknowledge in order to remove it will be displayed when the fuel level is low. Service: Perform a Total Upgrade according to TJ 31543.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Volvo has identified the painted surface under the exterior door handles may become scratched by the handles. The corrective action is add tape under all four (4) exterior door handles per TJ 32183.
Source components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a quality bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 vehicles. Volvo has identified the painted surface under the exterior door handles may become scratched by the handles. The corrective action is add tape under all four (4) exterior door handles per TJ 32183.
Source components: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Low battery State of Charge due to FMDM disturbance. When viewing the Quiescient Current Statistics in VIDA, vehicles with a regular FMDM disturbance will often show a number of counts in the 400-800mA range. If a vehicle with the latest software continues to have a low State of Charge and no cause can be found, replace the FMDM. Perform a Total Upgrade according to TJ 31543. The new FMDMs are not compatible with older CEM software.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Title Graphic HUD may loose height adjustment Head Up Display HUD/Does not work Under some conditions, the height adjustment for the Head Up Display (HUD) returns to its default (full "up") setting at a vehicle restart.At this time, there is no permanent solution to this problem.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Parts Bulletin: Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. If this condition should occur, it may result in moisture inside the passenger compartment, which could lead to air conditioning functionality issues. If the leakage has not been detected over a period of time, this condition could affect SRS systems (airbag), engine management systems etc. In such a case, the driver may experience various warning messages displayed in the Driver Information Module (DIM) identifying that a fault may be present and also providing guidance on how to proceed. Volvo therefore considers this a potential safety risk over time.
Source components: AIR BAGS · ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY · EQUIPMENT:APPLIANCE:AIR CONDITIONER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce squealing noise. Also replace front brake pads if vehicle is built before 15w19, or after 15w20 if the brake pads are worn down or there has been a previous attempt to grease or chamfer the pads to repair the car.
Source components: BACK OVER PREVENTION · SERVICE BRAKES, HYDRAULIC · SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor P/N 31442888 in the outer rear view mirror.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: P-SIM = Personal Subscriber Identity Module When using the in-car modem and P-SIM connection, the following symptoms may appear: 1 - In car apps such as TuneIn and Pandora connect to the service but say "Connecting..." when trying to play music. 2 - When a device is connected to the vehicle's WiFi hotspot, it will redirect to an AT&T website such as the one in the attachment Wifi Connection Message.jpg The above symptoms are due to the data plan for the P-SIM expiring. There is no fault with the vehicle. Should a customer present one of the above complaints, please direct them to the support site for instructions on how to renew the data plan for the P-SIM.
Source components: ELECTRICAL SYSTEM · EQUIPMENT ADAPTIVE/MOBILITY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: As of 11/28/2016 a voice recognition speech database file will no longer be included with the latest map upgrade for SPA vehicles (SPJ 29181) and must be downloaded separately from the maps. When performing PDS or diagnosing any voice control issue, always ensure that the latest speech database file is installed in the IHU.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: The front passenger seat heater may not start or turns itself off after a few minutes of driving. A new IHU (Integrated Head Unit) software with changed functionality has been introduced in week 46, 2016. Download a Total Upgrade in accordance with VIDA (Vehicle Information and Diagnostics for Aftersales) instructions and TJ 31543. The new software can be used on all cars from production start.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: The Remote Control slider button is now available as a spare part. If the slider button is missing or damaged, there is no need to replace the entire remote control. Install a new slider button (31419983) according to the attached instruction.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: * New VCM software release date CCD = Center Console Display DIM = Driver Information Module VCM = Vehicle Connectivity Master After upgrading an XC90 with the previous Total Upgrade software package, the navigation may show incorrect vehicle position in the CCD and DIM displays. This may happen intermittently or permanently. The customer may also see the vehicle position as incorrect in the Volvo On Call mobile app Service: *A further improved VCM software has been developed to prevent this symptom (now included in the current Total Upgrade, Service 2.0, and PDS software packages). It is available as of week 48, 2016. * Should a vehicle present this symptom, please perform a new Total Upgrade following software download guidelines in TJ 31543
NHTSA source summary · Original PDF not reviewed by Recallfolio
While performing repairs, on vehicles covered by Volvo's New Vehicle Warranty, the Technical Help Desk may support the dealer by providing a specific diagnostic labor operation. This will aid the Warranty Administrator when claiming reimbursement for diagnostic labor while not adversely affecting the dealers General Operation Index.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Leather seats, improvements on wrinkles and wear. Always replace both together, seat cushion upholstery and seat cushion foam . Both sides (Driver and/or passenger) should not be replaced as a pair if only one side has an issue. The backrest does not have to be replaced if only the seat cushion has an issue.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor P/N 31442888 in the outer rear view mirror.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: The front park assist sensor bracket may come loose from the lower grill. The clamping force on the bracket in the lower grill may be too low. Service: In case of customer complaints of a loose park assist sensor bracket, follow the instruction to assemble a foam block on the bracket to increase the clamping force.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be filled in and attached to the affected Vehicle Report. (External sources: Authority, Insurance companies, Rental companies, etc)
Source components: SERVICE BRAKES · SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Service Manager Bulletin: This bulletin contains information on the following steps which make up the Retail Car Delivery Process. ? Vehicle inspection procedure (Truck Delivery) ? Pre-Delivery Service (PDS) ? Vehicle in stock maintenance ? Vehicle Delivery (Customer Delivery) New car delivery is a crucial step in the Retail Car Delivery Process. At this point the buying experience turns into a long-term relationship. It is the retailer?s responsibility to ensure that the car and the experience are as enjoyable and informative as possible.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: Title Dash absorber insulation, Damp or bad smell Water seepage from sealing to Climate unit in plenum area. Add new sealing on the HWAS box (Humidity Water Air Separator) and secure assembly of the box according to attached instruction.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Update: NEW GROMMET AND PLUG PART NUMBERS REPLACE EXISTING DRAIN HOSES Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. If this condition should occur, it may result in moisture inside the passenger compartment, which could lead to air conditioning functionality issues.
Source components: ELECTRICAL SYSTEM · EQUIPMENT:APPLIANCE:AIR CONDITIONER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
After using a voice command to adjust the climate, the buttons for ?Forward?, ?Back? and ?Confirm? on the audio switches on the right side of the steering wheel may not function (marked as ?1?, ?2?and ?3? in attachment). The buttons ?Speech?, ?Open/Close Menu? and ?volume adjustment? are still operational. See https://youtu.be/OLdEk-NskVQ
NHTSA source summary · Original PDF not reviewed by Recallfolio
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89708 on certain model year 2016 - 2017 XC90, S90, XC60, V60CC, V60, S60, S60CC, S60 Inscription vehicles. The affected vehicles may have not had the front passenger seatbelt buckle stud punched correctly. This may result in a separation between the buckle and the seat belt bracket. If this were to occur, it could increase the risk of injury to a front passenger seat occupant in a vehicle crash.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. If this condition should occur, it may result in moisture inside the passenger compartment, which could lead to air conditioning functionality issues.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A SERVICE MANAGER BULLETIN: THIS BULLETIN CONTAINS INFORMATION ON THE FOLLOWING STEPS WHICH MAKE UP THE RETAIL CAR DELIVERY PROCESS. VEHICLE INSPECTION PROCEDURE (TRUCK DELIVERY) PRE-DELIVERY SERVICE (PDS) VEHICLE IN STOCK MAINTENANCE VEHICLE DELIVERY (CUSTOMER DELIVERY) NEW CAR DELIVERY IS A CRUCIAL STEP IN THE RETAIL CAR DELIVERY PROCESS. AT THIS POINT THE BUYING EXPERIENCE TURNS INTO A LONG-TERM RELATIONSHIP. IT IS THE RETAILERS RESPONSIBILITY TO ENSURE THAT THE CAR AND THE EXPERIENCE ARE AS ENJOYABLE AND INFORMATIVE AS POSSIBLE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A PARTS BULLETIN: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE.THE CORRECTIVE ACTION IS TO CHECK THE VEHICLES IGM SERIAL NUMBER AGAINST THE ATTACHED IGM HOUSING SERIAL NUMBERS LIST. IF THE LABEL NUMBER FOR THE VEHICLES IGM IS LISTED IN THE IGM HOUSING SERIAL NUMBER LIST, REPLACE THE IGM. IF THE LABEL NUMBER FROM THE VEHICLES IGM IS NOT ON THE LIST, NO FURTHER ACTION IS NECESSARY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A QUALITY BULLETIN: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE.THE CORRECTIVE ACTION IS TO CHECK THE VEHICLES IGM SERIAL NUMBER AGAINST THE ATTACHED IGM HOUSING SERIAL NUMBERS LIST. IF THE LABEL NUMBER FOR THE VEHICLES IGM IS LISTED IN THE IGM HOUSING SERIAL NUMBER LIST, REPLACE THE IGM. IF THE LABEL NUMBER FROM THE VEHICLES IGM IS NOT ON THE LIST, NO FURTHER ACTION IS NECESSARY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE.THE CORRECTIVE ACTION IS TO CHECK THE VEHICLES IGM SERIAL NUMBER AGAINST THE ATTACHED IGM HOUSING SERIAL NUMBERS LIST. IF THE LABEL NUMBER FOR THE VEHICLES IGM IS LISTED IN THE IGM HOUSING SERIAL NUMBER LIST, REPLACE THE IGM. IF THE LABEL NUMBER FROM THE VEHICLES IGM IS NOT ON THE LIST, NO FURTHER ACTION IS NECESSARY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL: CONDENSATION WATER, TRANSFERRED THROUGH THE AIR CONDITIONING DRAIN HOSE, MAY LEAK INTO THE PASSENGER COMPARTMENT DUE TO INCORRECT INSTALLATION DURING VEHICLE ASSEMBLY. IF THIS CONDITION SHOULD OCCUR, IT MAY RESULT IN MOISTURE INSIDE THE PASSENGER COMPARTMENT, WHICH COULD LEAD TO AIR CONDITIONING FUNCTIONALITY ISSUES. IF THE LEAKAGE HAS NOT BEEN DETECTED OVER A PERIOD OF TIME, THIS CONDITION COULD AFFECT SRS SYSTEMS (AIRBAG), ENGINE MANAGEMENT SYSTEMS ETC. IN SUCH A CASE, THE DRIVER MAY EXPERIENCE VARIOUS WARNING MESSAGES DISPLAYED IN THE DRIVER INFORMATION MODULE (DIM) IDENTIFYING THAT A FAULT MAY BE PRESENT AND ALSO PROVIDING GUIDANCE ON HOW TO PROCEED. VOLVO THEREFORE CONSIDERS THIS A POTENTIAL SAFETY RISK OVER TIME.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE UNEXPECTED CLIMATE REGULATION DURING DRIVING, CLIMATE SYSTEM MIGHT SUDDENLY STARTS TO BLOW HOT/COLD AIR. CCM SW NOW IMPLEMENTED 2016W38 IN PRODUCTION AND FOR SERVICE. IN CASE OF CUSTOMER COMPLAINTS, PERFORM CCM SW UPGRADE ACCORDING TO VIDA. CHASSIS BREAK WILL BE UPDATED WHEN AVAILABLE.
Source components: ENGINE AND ENGINE COOLING · EQUIPMENT:APPLIANCE:AIR CONDITIONER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL: AN IMPROVED AND MORE ROBUST CCD (CENTER CONSOLE DISPLAY) HAS BEEN INTRODUCED FOR MY 2017. THE NEW DISPLAY IS MORE RESISTANT TO SURFACE SCRATCHES. THE SCREEN PROTECTION FILM IS THEREFORE NOT SUPPLIED WITH THE VEHICLE FROM THE FACTORY FROM THE ABOVE CHASSIS BREAK POINTS. SERVICE: THE PROTECTIVE FILM IS NO LONGER SUPPLIED WITH THE VEHICLE FROM FACTORY AFTER CHASSIS BREAK POINTS ABOVE AND MUST NOT BE CLAIMED UNDER WARRANTY. THE NEW CCD INTRODUCED FOR MY 2017 SUPERSEDES THE PREVIOUS CCD AS SPARE PART.
Source components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL: IT IS PROVIDED AS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. FOLLOW INSTRUCTIONS PROVIDED FOR PROPER SOFTWARE DOWNLOADS BY YEAR AND MODEL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A SERVICE MANAGER BULLETIN: OCCASIONALLY, CUSTOMERS REQUEST FINANCIAL ASSISTANCE WHEN THE NEW CAR LIMITED WARRANTY, CPO LIMITED WARRANTY AND/OR THE VIP EXTENDED WARRANTY DOES NOT APPLY. THESE REQUESTS MAY BE CONSIDERED IF IT WILL ENHANCE OWNER RETENTION. RETAILERS SHOULD REQUEST FINANCIAL ASSISTANCE FOR THEIR CUSTOMERS BY CONTACTING THEIR AFTERSALES MARKET MANAGER (AMM), IF THEY ARE NOT A SELF-AUTHORIZING (LEVEL A) RETAIL FACILITY
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL: IT IS PROVIDED AS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. FOLLOW INSTRUCTIONS PROVIDED FOR PROPER SOFTWARE DOWNLOADS BY YEAR AND MODEL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
SPECIAL TOOL BULLETIN: VOLVO MANDATORY SPECIAL TOOLS ARE NECESSARY FOR TECHNICIAN TO PROPERLY DIAGNOSE AND REPAIR VOLVO CARS. THEY ARE USED IN DEVELOPMENT OF VOLVO LABOR OPERATIONS AND REPAIR METHODS, AND PROMOTE SAFETY AND QUALITY REPAIRS IN A TIMELY MANNER. TOOLS ARE CLASSIFIED AS MANDATORY BECAUSE ASSOCIATED REPAIRS AND/OR DIAGNOSTICS CANNOT BE COMPLETED PROPERLY WITHOUT THEM.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: The front park assist sensor bracket may come loose from the lower grill. The clamping force on the bracket in the lower grill may be too low. Service: In case of customer complaints of a loose park assist sensor bracket, follow the instruction to assemble a foam block on the bracket to increase the clamping force.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. 31471266 Comfort brake pads, only for cars with VDN code RC02 An improved rear brake disc with changed composition is planned to be available in the end of June 2016, For cars built before chassis number 22196, replace rear brake pads according to VIDA. For cars built after chassis number 22196 or are already have the latest brake pads, try to hold the repair until the new rear brake disc is available.
Source components: SERVICE BRAKES, AIR:DISC:PADS · SERVICE BRAKES, HYDRAULIC · SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Parts Bulletin was issued to Parts Managers, Please return stock of part number's 31406337, 31406349, 31406350 bushing kits to your servicing distribution center. New versions are 31476221, 31476223, 31476222
NHTSA source summary · Original PDF not reviewed by Recallfolio
This document is a Technical Journal: Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. For battery replacements under warranty, the code generated by the BT3300 must be manually copied into the repair order text. It must also be printed and attached to the hard copy of the repair order.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This document is a Technical Journal: A rattling noise may occur while closing the front door with the window in down position. Only vehicles with non-laminated glass can be affected. Add a felt tape P/N 30788314 (max 2 mm thickness) on the front door glass run channel according to service instruction.
Source components: STRUCTURE:BODY:DOOR · VISIBILITY:POWER WINDOW DEVICES AND CONTROLS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This document is a Service Product Journal: Memory used for VIDA is not fully optimized and below examples of symptoms might therefore occur. VIDA will run slow after some time. VIDA might freeze. Certain operations might stop working. In order to release stored session memory, restart VIDA as needed throughout the day in order to minimize the risk to experience above symptoms.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This document is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. 31471266 Comfort brake pads, only for cars with VDN code RC02 An improved rear brake disc with changed composition is planned to be available in the end of June 2016, For cars built before chassis number 22196, replace rear brake pads according to VIDA. For cars built after chassis number 22196 or are already have the latest brake pads, try to hold the repair until the new rear brake disc is available.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This document is a Technical Journal: In the event of a damaged floor harness, Instead of replacing terminals, a floor harness can be repaired according to the method in VIDA under Bulletins/ Product fix/Special tools Bulletins/3 Electrical/ 371 Cables.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This document is a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
NHTSA source summary · Original PDF not reviewed by Recallfolio
This TJ is only valid for SPA cars equipped with a CD player (also referred to as ODP or Optical Disc Player). If there is a problem loading software to a car equipped with a CD player, follow the instructions in TJ 31360
NHTSA source summary · Original PDF not reviewed by Recallfolio
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. 31471266 Comfort brake pads, only for cars with VDN code RC02 An improved rear brake disc with changed composition is planned to be available in the end of June 2016, For cars built before chassis number 22196, replace rear brake pads according to VIDA. For cars built after chassis number 22196 or are already have the latest brake pads, try to hold the repair until the new rear brake disc is available.
Source components: SERVICE BRAKES, AIR:DISC:PADS · SERVICE BRAKES, HYDRAULIC · SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
A new feature will be available in VIDA version 16.4 where by users will be automatically informed when their passwords are about to expire. The pop-up window example, in the attachment, will be shown 14 days prior to the expiraton date. When this occurs, please change the password as soon as possible, in order to prevent from being locked out.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Below error message may be shown in VIDA when selecting the Software tab in VIDA. With this message, it will not be possible to purchase Software Products. "124 - Client ID is not registered"
NHTSA source summary · Original PDF not reviewed by Recallfolio
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service.
NHTSA source summary · Original PDF not reviewed by Recallfolio
If a front door deco panel is replaced, it may be hard to mount the new one on the door panel. If the steel clips on the new deco panel are black, remove the steel clip It will sit tight with the remaining clips. The hole will be adjusted in production to align better with the clip. (The metal colored, old type of clips has less precision and therefore fits in the hole.)
NHTSA source summary · Original PDF not reviewed by Recallfolio
The Volvo Technical Helpdesk (THD) is a central contact point available to authorized Volvo dealer technicians to assist with difficult to repair situations. If for some reason our technical experts cannot solve an issue directly, it will be escalated appropriately for further in-depth assistance to your local Field Technical specialist (FTS).
NHTSA source summary · Original PDF not reviewed by Recallfolio
If the vehicle is equipped with a tire pressure monitoring system (TPMS), please be aware that the TPMS system has changed from MY 2017 (structure week 2016 week 17).Now an Indirect TPMS system is being used (I-TPMS). The Direct TPMS system (D-TPMS) that was used in XC90 MY 2016 is no longer used in production from MY 2017.
Source components: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service.
NHTSA source summary · Original PDF not reviewed by Recallfolio
All new Volvo engines leave the factory filled with Castrol EDGE Professional as an integral part of their delivery of high performance. Castrol EDGE Professional?s outstanding performance has made it the oil of choice for Volvo and is the only Volvo recommended engine oil.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Blisters/bubbles may appear on the air vent surfaces. The blistering of the material is often caused by an air freshener applied directly to the air vents. Do not attach any sort of air freshener directly on air vents.
NHTSA source summary · Original PDF not reviewed by Recallfolio
If you need to perform a tuner replacement on any vehicle that is factory equipped with SiriusXM satellite radio, please follow the step by step instructions. Going through this process will ensure your customer continues to receive their satellite radio programming without any interruption of service. For SPA vehicles, the SiriusXM tuner is contained within the Infotainment Head Unit (IHU). For all other vehicles, the tuner is the Remote Digital Audio Receiver (RDAR).
NHTSA source summary · Original PDF not reviewed by Recallfolio
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. 31471266 Comfort brake pads, only for cars with VDN code RC02 An improved rear brake disc with changed composition is planned to be available in the end of June 2016, For cars built before chassis number 22196, replace rear brake pads according to VIDA. For cars built after chassis number 22196 or are already have the latest brake pads, try to hold the repair until the new rear brake disc is available.
Source components: BACK OVER PREVENTION · SERVICE BRAKES, HYDRAULIC.
NHTSA source summary · Original PDF not reviewed by Recallfolio
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is wateringress into rear park assist sensors and connectors caused by splices in the rear cable harness. If the sensors and connectors have water ingress then follow method in VIDA
NHTSA source summary · Original PDF not reviewed by Recallfolio
There has been an increasing amount of reports where users state that its not possible to perform a vehicle readout when pressing ?Connect? There will be an error message asking the user if they wants to retry after an error message saying ?Error occurred during complete read out for VIN ?This error message is generic and could be caused by other problems
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A SPECIAL TOOL : SUITABLE FOR ALL VEHICLE MODELS EQUIPPED WITH TPMS (TIRE PRESSURE MONITOR SYSTEM). THE TOOL AUTOMATICALLY TESTS SCHRAEDER AND CONTINENTAL TPMS SENSOR.
Source components: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL : FOR A NO CRANK, NO START CONDITION WHERE THE OBC (ON BOARD CHARGER) IS NOT RESPONDING IN VIDA (OBC_NOT_RESPONDING.JPG), AND THERE ARE NO RELATED DTCS, FOLLOW PROCEDURE UNDER SERVICE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A SERVICE PRODUCT JOURNAL : THE PREVIOUSLY REPORTED ISSUE WITH VIDA 2015 AND BATTERY TESTING HAS BEEN RESOLVED. VIDA 2015 BATTERY TESTING IS THE ONLY APPROVED METHOD FOR PRODUCING BATTERY TEST CODES. THE USE OF VIDA CLASSIC OR OTHER MEASURING TOOLS IS NOT CONSIDERED ACCEPTABLE WHEN SUBMITTING WARRANTY CLAIMS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A TECHNICAL JOURNAL : WHEN ANY REPAIR IS MADE ON ENGINE COOLING SYSTEM, MAKE SURE THAT THE VOLVO SPECIAL TOOL P/N 9512957 COOLANT FILLING EQUIPMENT IS USED, IN ORDER TO PREVENT FUTURE OVER TEMPERATURE DAMAGE ON ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS IS A SERVICE PRODUCT JOURNAL : WHEN PERFORMING SOFTWARE DOWNLOADS TO A VEHICLE THERE MIGHT BE AN UNHANDLED SCRIPT EXCEPTION OR ERROR MESSAGE. WE DONT HAVE THE FULL SCOPE ON WHICH SOFTWARES ARE AFFECTED BY THIS.
Source components: ELECTRICAL SYSTEM · ELECTRICAL SYSTEM:SOFTWARE.