Original record summaries, dates and identifiers for this model-year. Records 801–900 of 1,331, ordered newest first. Dated records on this page: Nov 22, 2013–Mar 27, 2014.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Mar 27, 2014Service Bulletin/Repair Instructions
V871401 2005566
NHTSA communication ID: 10124289
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Sunroof / Sunshade, Will Not Open): The panoramic sunroof, regular sunroof or sunshade cannot be opened. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster): Airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. This document informs on how to diagnose that this issue is taking place
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: AIRBAG WARNING LIGHT WAS ILLUMINATED INDICATING A FRONT SIDE AIRBAG PRESSURE SENSOR INTERRUPTION/SHORT TO B+. THE DTCS B101715 AND B103615. *JS
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (No Start, or Rough Running due to Fuel Rail issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the High Pressure Fuel Pump using the service section of this document. If such an inspection is necessary, the following guidelines must be observed when removing the N290 Fuel Metering Valve.
Source components: ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Manifold Absolute Pressure Range / Performance Stored in ECM Fault Memory): Monitoring strategy for the manifold absolute pressure sensor is too sensitive, causing P0106 to incorrectly set in the engine control module. The product solution for this issue was improved software.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (No Start, or Rough Running issues): When diagnosing a MIL ON, no-start or rough running concern on a common rail diesel vehicle, and no root cause is found after following all GFF diagnostic procedures, it may be necessary to check for metallic particles in the High Pressure Fuel Pump. If such an inspection is necessary, the guidelines in this document must be observed when removing the N290 Fuel Metering Valve
Source components: ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Update Programming to Eliminate DTC P050A Stored in ECM Fault Memory
Source components: ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE · POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE · SERVICE BRAKES, ELECTRIC.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE AN ILLUMINATED BRAKE WARNING LIGHT. UPDATED THE PROGRAMMING ECM TO ELIMINATE DTC 03366 STORED IN THE FAULT MEMORY. *JS
NHTSA source summary · Original PDF not reviewed by Recallfolio
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.
NHTSA source summary · Original PDF not reviewed by Recallfolio
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM 09117.
Source components: ELECTRICAL SYSTEM · ELECTRICAL SYSTEM:IGNITION:SWITCH · UNKNOWN OR OTHER · VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT apply shop air to the dipstick tube or the crankcase. If a rear main seal leak is identified, replace the seal.
Source components: ENGINE AND ENGINE COOLING · POWER TRAIN.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of engine issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
NHTSA source summary · Original PDF not reviewed by Recallfolio
Fuel injector seals are available separately for service repairs. It is not necessary to replace the complete fuel injector if a seal (upper or lower) is needed. Please see ETKA for the latest parts information.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Fuel injector seals for 2.0L (CBPA) engine code): Fuel injector seals are available separately for service repairs. It is not necessary to replace the complete fuel injector if a seal (upper or lower) is needed.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (A/C Control Module Basic Settings): This document informs how to set basic setting on the Climatic control module after replacement for fault code 00898
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (A/C Control Module Basic Settings): This document informs how to set basic setting on the Climatic control module after replacement for fault code 00898
Source components: ELECTRICAL SYSTEM · EQUIPMENT:APPLIANCE:AIR CONDITIONER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Fuel injector seals for 2.0L (CBPA) engine code): Fuel injector seals are available separately for service repairs. It is not necessary to replace the complete fuel injector if a seal (upper or lower) is needed.
NHTSA source summary · Original PDF not reviewed by Recallfolio
On the vehicles listed above, the auto unlock feature will only unlock the door(s) that were unlocked when the vehicle was last entered. For example, if the vehicle is set to unlock only the driver?s door on first press of the unlock button on the keyless entry remote (or when using the door handle on KESSY equipped vehicles) and only the driver?s door is unlocked during entry, only the driver?s door will unlock with the auto unlock feature when placed into park or the key is removed from the ignition. This is normal operation, normal characteristic and no diagnosis or repair should be attempted for this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (No Charging System Voltage): This document informs with a general overview of how to inspect and diagnosing a low battery or no charging system concern.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Auto Unlock Function): On the vehicles listed above, the auto unlock feature will only unlock the door(s) that were unlocked when the vehicle was last entered. For example, if the vehicle is set to unlock only the driver's door on first press of the unlock button on the keyless entry remote (or when using the door handle on KESSY equipped vehicles) and only the driver's door is unlocked during entry, only the driver's door will unlock with the auto unlock feature when placed into park or the key is removed from the ignition. This is normal operation, normal characteristic and no diagnosis or repair should be attempted for this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Auto Unlock Function): On the vehicles listed above, the auto unlock feature will only unlock the door(s) that were unlocked when the vehicle was last entered. For example, if the vehicle is set to unlock only the driver?s door on first press of the unlock button on the keyless entry remote (or when using the door handle on KESSY equipped vehicles) and only the driver?s door is unlocked during entry, only the driver?s door will unlock with the auto unlock feature when placed into park or the key is removed from the ignition. This is normal operation, normal characteristic and no diagnosis or repair should be attempted for this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (No Charging System Voltage): This document informs with a general overview of how to inspect and diagnosing a low battery or no charging system concern.
Source components: ELECTRICAL SYSTEM · ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM.
NHTSA source summary · Original PDF not reviewed by Recallfolio
A concern of water leak into the front passenger compartment may be caused by a seam sealer skip or hole in the area around hood hinge or behind front fender.
Source components: STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Water Leak into Front Passenger Compartment): A concern of water leak into the front passenger compartment may be caused by a seam sealer skip or hole in the area around hood hinge or behind front fender. This document informs of the procedure to Isolate leak locations.