The manufacturer’s record · Page 7 of 16
Original record summaries, dates and identifiers for this model-year. Records 601–700 of 1,504, ordered newest first. Dated records on this page: Feb 23, 2017–Nov 29, 2017.
Back to 2014 Chevrolet SONIC problems & recallsThis archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
NHTSA communication ID: 10140338
NHTSA source summary · Original PDF not reviewed by Recallfolio
This technical bulletin provides a procedure to replace the evap canister for vehicles with the condition of Malfunction Indicator Lamp (MIL) Illuminated with DTC P0446 or P0455 Set due to spiders laying a nest within the canister.
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL.
Source record 10140338 at NHTSANHTSA communication ID: 10140340
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary information bulletin provides a procedure on how to check for the customer concern of a blank radio with/without audio, by checking the the wiring harness, ECU and reprograming the HMI software update, if the wiring or ECU are not the cause.
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10140340 at NHTSANHTSA communication ID: 10139095
NHTSA source summary · Original PDF not reviewed by Recallfolio
This bulletin describes the Dealer special tool loan program process.
Source components: EQUIPMENT.
Source record 10139095 at NHTSANHTSA communication ID: 10139089
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information to dealership personnel on automatic transmission shift and engine drivability concerns and/or MIL ON due to aftermarket oil bath air filter use.
Source components: ENGINE · EQUIPMENT · POWER TRAIN.
Source record 10139089 at NHTSANHTSA communication ID: 10125122
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that the keyless entry is inoperative. Technician should inspect the ignition key cylinder door sticks in the up position. If the door is found open do not replace the ignition key cylinder, use a Lubriplate type of lubrication spray and lubricate the ignition key cylinder door. Insert the tip of the key in and out to verify the door of the cylinder is not sticking.
Source components: ELECTRICAL SYSTEM:IGNITION.
Source record 10125122 at NHTSANHTSA communication ID: 10139118
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides a listing of the parts availability for coax repair procedures and what is needed to complete some repairs.
Source components: EQUIPMENT.
Source record 10139118 at NHTSANHTSA communication ID: 10139090
NHTSA source summary · Original PDF not reviewed by Recallfolio
This technical bulletin provides repair information for repairing the IP to body harness connector to correct a customer concern for intermittent Malfunction Indicator Lamp (MIL) illuminated with Reduced Engine Power displayed and DTC P2138 set.
Source components: ELECTRICAL SYSTEM · ENGINE.
Source record 10139090 at NHTSANHTSA communication ID: 10125106
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. Technician should obtain a hand-held GPS unit to test the odometer. If a hand held GPS unit is not available, the only other option is to verify the miles traveled using a surveyor's wheel or a dynamometer.
Source components: ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL.
Source record 10125106 at NHTSANHTSA communication ID: 10134594
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides dealership personnel with policy and procedure requirements for essential tools that include consumable parts (U.S. Only).
Source components: ENGINE · EQUIPMENT.
Source record 10134594 at NHTSANHTSA communication ID: 10134621
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
Source components: EQUIPMENT.
Source record 10134621 at NHTSANHTSA communication ID: 10134592
NHTSA source summary · Original PDF not reviewed by Recallfolio
The information in this bulletin details the proper configurations for the ignition key, fob, key tags, key rings, key ring sizes and applying a QR code sticker or barcode sticker to a key fob.
Source components: ELECTRICAL SYSTEM:IGNITION · ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE.
Source record 10134592 at NHTSANHTSA communication ID: 10123269
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that may have a Malfunction Indicator Lamp on. The technician may find Diagnostic Trouble Codes P0299 or P0234 set. The technician is provided with a list of causes of misdiagnosis leading to returned Turbochargers with no trouble found.The purpose of this information is to reduce the number of no trouble found (NTF) turbochargers being returned to the WPC by informing the Service Department personnel of what inspections and/or diagnosis toperform, prior to replacing and returning a turbocharger to the WPC.
Source components: EQUIPMENT:ELECTRICAL.
Source record 10123269 at NHTSANHTSA communication ID: 10123252
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency Identification Devices when the concern is present. Dealer should also direct their customers to the appropriate section in the Owner manuals that references that the device complies.
Source components: ELECTRICAL SYSTEM · EQUIPMENT.
Source record 10123252 at NHTSANHTSA communication ID: 10134593
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered seepage.
Source components: EQUIPMENT.
Source record 10134593 at NHTSANHTSA communication ID: 10123227
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D-37 history in the Vehicle Communication Interface Module or telematics communication interface control module. Engineering has determined that this code will only display in history on the scan tool and will not cause issues with OnStar system operation.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10123227 at NHTSANHTSA communication ID: 10123222
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availability.
Source components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10123222 at NHTSANHTSA communication ID: 10190338
NHTSA source summary · Original PDF not reviewed by Recallfolio
Essential Tools that Include Consumable Parts (U.S. Only)
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10190338 at NHTSANHTSA communication ID: 10190337
NHTSA source summary · Original PDF not reviewed by Recallfolio
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to unnecessary component replacement. Use the following information to determine if the condition is normal acceptable seepage or a defective component
Source components: SUSPENSION:FRONT:MACPHERSON STRUT · SUSPENSION:FRONT:SHOCK ABSORBER · SUSPENSION:REAR:SHOCK ABSORBER.
Source record 10190337 at NHTSANHTSA communication ID: 10190336
NHTSA source summary · Original PDF not reviewed by Recallfolio
Information for Fleet Vehicles Ignition Key, Fob and Key Rings Configuration Some Customers are bundling multiple keys, fobs, and key tags together on a single crimped loop or a cable. This practice may result in unintended key rotation, and should be discontinued immediately. The information in this bulletin details the proper configurations for the ignition key, fob, key rings and key tags and applying a QR code sticker or barcode sticker to a key fob.
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10190336 at NHTSANHTSA communication ID: 10190321
NHTSA source summary · Original PDF not reviewed by Recallfolio
Information for Fleet Vehicles Ignition Key, Fob and Key Rings Configuration Some Customers are bundling multiple keys, fobs, and key tags together on a single crimped loop or a cable. This practice may result in unintended key rotation, and should be discontinued immediately. The information in this bulletin details the proper configurations for the ignition key, fob, key rings and key tags and applying a QR code sticker or barcode sticker to a key fob.
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10190321 at NHTSANHTSA communication ID: 10190320
NHTSA source summary · Original PDF not reviewed by Recallfolio
IPC Odometer Programming Method Quick Reference Guide
Source components: ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT · EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10190320 at NHTSANHTSA communication ID: 10157041
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will use Global Diagnostic System 2 to review the Firmware Over-the-Air version. If the Firmware Over-the-Air version on the scan tool equals 6708 the technician will need to contact General Motors Technical Assistance Center for further assistance. If the Firmware Over-the-Air version on the scan tool is lower than 6708 Dealer can order the part thought the Instrument Sales and Service website process.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10157041 at NHTSANHTSA communication ID: 10159570
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides policy information on the requirements for battery testing and warranty replacements.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10159570 at NHTSANHTSA communication ID: 10157020
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
Source components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10157020 at NHTSANHTSA communication ID: 10157018
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT · FUEL SYSTEM, GASOLINE · TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS.
Source record 10157018 at NHTSANHTSA communication ID: 10159575
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty admin bulletin explains to the technician additional information may be needed when submitting transactions when doing wiring repairs.
Source components: ELECTRICAL SYSTEM:WIRING.
Source record 10159575 at NHTSANHTSA communication ID: 10159572
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin explains the importance of maintaining the vehicle.
Source components: EQUIPMENT.
Source record 10159572 at NHTSANHTSA communication ID: 10159569
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on gasket sealing surfaces or reused parts.
Source components: ENGINE AND ENGINE COOLING · EQUIPMENT.
Source record 10159569 at NHTSANHTSA communication ID: 10156999
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY · EQUIPMENT:ELECTRICAL.
Source record 10156999 at NHTSANHTSA communication ID: 10156990
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technicians may also contact Partech and/or the Techline Customer Support Center for additional support.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10156990 at NHTSANHTSA communication ID: 10159574
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Internal Engine Noise or Damage After Oil Filter Replacement.
Source components: ENGINE.
Source record 10159574 at NHTSANHTSA communication ID: 10140293
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Intake Manifold Inspection/Replacement After Severe Internal Engine Damage.
Source components: ENGINE AND ENGINE COOLING.
Source record 10140293 at NHTSANHTSA communication ID: 10140298
NHTSA source summary · Original PDF not reviewed by Recallfolio
The intent of this technical bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
Source components: EQUIPMENT:ELECTRICAL.
Source record 10140298 at NHTSANHTSA communication ID: 10140406
NHTSA source summary · Original PDF not reviewed by Recallfolio
Thins informational bulletin provides information on Paint-less Dent Repair Process.
Source components: EQUIPMENT · STRUCTURE.
Source record 10140406 at NHTSANHTSA communication ID: 10140294
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin communicates part restriction and ordering process information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only).
Source components: ELECTRICAL SYSTEM.
Source record 10140294 at NHTSANHTSA communication ID: 10137727
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, An out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.
Source components: ENGINE.
Source record 10137727 at NHTSANHTSA communication ID: 10137724
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that have excessive oil consumption, blue smoke from the exhaust, or a Malfunction Indicator Lamp. Technician should inspect the PVC orifice for leaking oil or drawing a vacuum at idle. If the PCV orifice external port is leaking oil or vacuum, replace the camshaft cover assembly. Technician will inspect for a missing intake manifold Non Return Valve that may have damaged the PCV orifice diaphragm. Check for the return valve if it is not visible use a long cotton swab to wipe any excess oil from the valve to validate. If the non return valve is still not visible, then intake manifold removal for inspection is required to validate. When the valve is present reinstall the intake manifold. When the valve is not present replace the intake manifold assembly.
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV).
Source record 10137724 at NHTSANHTSA communication ID: 10140373
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides to the technician, locations to check for possible loose or damaged electrical connections that may set a DTC instead of just replacing a part.
Source components: ELECTRICAL SYSTEM.
Source record 10140373 at NHTSANHTSA communication ID: 10137714
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that the keyless entry is inoperative. Technician should inspect the ignition key cylinder door sticks in the up position. If the door is found open do not replace the ignition key cylinder, use a Lubriplate type of lubrication spray and lubricate the ignition key cylinder door. Insert the tip of the key in and out to verify the door of the cylinder is not sticking.
Source components: ELECTRICAL SYSTEM:IGNITION.
Source record 10137714 at NHTSANHTSA communication ID: 10137713
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that the keyless entry is inoperative. Technician should inspect the ignition key cylinder door sticks in the up position. If the door is found open do not replace the ignition key cylinder, use a Lubriplate type of lubrication spray and lubricate the ignition key cylinder door. Insert the tip of the key in and out to verify the door of the cylinder is not sticking.
Source components: ELECTRICAL SYSTEM:IGNITION · ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE.
Source record 10137713 at NHTSANHTSA communication ID: 10137706
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on. Technician will find Diagnostic Trouble Code P0341 and or P0366 set. If theconcern is duplicated, the technician is directed toreplace the related Camshaft Position sensor and retest for the code. If the Diagnostic Trouble Code returns technician should check the history to see if the vehicle was in a collision. If the vehicle has been in a collision, the technician is advised onrepair direction.
Source components: ENGINE.
Source record 10137706 at NHTSANHTSA communication ID: 10137705
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about customers that may complain of various concerns when using Bluetooth components. Technician should use the Preliminary Information to gather information from the customer on their Bluetooth device and the concern they are having before calling General Motors Technical Assistance Center.
Source components: EQUIPMENT:ELECTRICAL.
Source record 10137705 at NHTSANHTSA communication ID: 10140296
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information on required operating procedures.
Source components: EQUIPMENT.
Source record 10140296 at NHTSANHTSA communication ID: 10140297
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information on warranty and policy exchange program for electronic products for U.S. and Canada dealers only.
Source components: EQUIPMENT.
Source record 10140297 at NHTSANHTSA communication ID: 10126081
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin explains the Road Force balancers and what they can do for customer concerns.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10126081 at NHTSANHTSA communication ID: 10126083
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information for dealers and technicians about the 1.4L turbocharged engine use two different suppliers for the oil filter housing which results in two different filters being used.
Source components: ENGINE.
Source record 10126083 at NHTSANHTSA communication ID: 10126113
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Information on How to Prevent Inadvertent Vehicle Starting from Key Fob or OnStar Mobile Application and where to locate the information for future use.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10126113 at NHTSANHTSA communication ID: 10126068
NHTSA source summary · Original PDF not reviewed by Recallfolio
This technical bulletin provides information on Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing and the procedures to turn the transport mode message on and off.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10126068 at NHTSANHTSA communication ID: 10126065
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information on required operating procedures.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10126065 at NHTSANHTSA communication ID: 10108645
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on the temporary tire flat spotting condition.
Source components: TIRES.
Source record 10108645 at NHTSANHTSA communication ID: 10114082
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary information communicatesIn ambient temperatures 100F (37.7 C)degrees or higher, DTCs P2635 and/or P018B may set.The vehicle may also exhibit a hesitation or stalling condition.Excessively Hot and sustained ambient temperatures over 100F (37.7 C) degrees Mainly in TX, AZ, UT, NV, CA, NM (could be any state) causingVapor buildup in fuel feed line.Customers can be advised to utilize fuels with octane levels greater than 91, Refrain from extended idleing periods if possible, park vehicles in covered garage.Replacing the fuel pump will not repare this concern.
Source components: FUEL SYSTEM, GASOLINE · FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP.
Source record 10114082 at NHTSANHTSA communication ID: 10108627
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
Source components: ENGINE · EQUIPMENT.
Source record 10108627 at NHTSANHTSA communication ID: 10108626
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
Source components: ELECTRICAL SYSTEM:WIRING.
Source record 10108626 at NHTSANHTSA communication ID: 10108625
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
Source components: ENGINE · EQUIPMENT.
Source record 10108625 at NHTSANHTSA communication ID: 10108609
NHTSA source summary · Original PDF not reviewed by Recallfolio
This technical bulletin provides a procedure to complete a wire to wire repair on the engine wire harness to correct a condition of no start, Malfunction Indicator Lamp (MIL) ON, and possible loss of steering assist.
Source components: ELECTRICAL SYSTEM:WIRING · ENGINE.
Source record 10108609 at NHTSANHTSA communication ID: 10114072
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about the rear view camera options on the vehicles equipped with rear view camera. The rear view camera brightness can be adjusted on some models while the transmission is in reverse and using the Menu or Select button. To turn off or on the guidelines in the rear view camera, use the radio display Config icon then Display, then the guidelines option.
Source components: BACK OVER PREVENTION: CAMERA SYSTEM · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10114072 at NHTSANHTSA communication ID: 10114071
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary information communicatesIn ambient temperatures 100F (37.7 C)degrees or higher, DTCs P2635 and/or P018B may set.The vehicle may also exhibit a hesitation or stalling condition.Excessively Hot and sustained ambient temperatures over 100F (37.7 C) degrees Mainly in TX, AZ, UT, NV, CA, NM (could be any state) causingVapor buildup in fuel feed line.Customers can be advised to utilize fuels with octane levels greater than 91, Refrain from extended idleing periods if possible, park vehicles in covered garage.Replacing the fuel pump will not repare this concern.
Source components: FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP.
Source record 10114071 at NHTSANHTSA communication ID: 10118290
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary information communicatesIn ambient temperatures 100F (37.7 C)degrees or higher, DTCs P2635 and/or P018B may set.The vehicle may also exhibit a hesitation or stalling condition.Excessively Hot and sustained ambient temperatures over 100F (37.7 C) degrees Mainly in TX, AZ, UT, NV, CA, NM (could be any state) causingVapor buildup in fuel feed line.Customers can be advised to utilize fuels with octane levels greater than 91, Refrain from extended idleing periods if possible, park vehicles in covered garage.Replacing the fuel pump will not repare this concern.
Source components: EQUIPMENT.
Source record 10118290 at NHTSANHTSA communication ID: 10118261
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that may have a Malfunction Indicator Lamp on. The technician may find Diagnostic Trouble Codes P0299 or P0234 set. The technician is provided with a list of causes of misdiagnosis leading to returned Turbochargers with no trouble found.The purpose of this information is to reduce the number of no trouble found (NTF) turbochargers being returned to the WPC by informing the Service Department personnel of what inspections and/or diagnosis toperform, prior to replacing and returning a turbocharger to the WPC.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10118261 at NHTSANHTSA communication ID: 10118256
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the activation is initiated by a Service Programming System. For the 2010 and UP model year vehicles, the OnStar set-up procedure and OnStar Activation request have been combined into a single programming event called OnStar Set-up and Activation in Service Programming System.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10118256 at NHTSANHTSA communication ID: 10118254
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that may have a Malfunction Indicator Lamp on. The technician may find Diagnostic Trouble Codes P0299 or P0234 set. The technician is provided with a list of causes of misdiagnosis leading to returned Turbochargers with no trouble found.The purpose of this information is to reduce the number of no trouble found (NTF) turbochargers being returned to the WPC by informing the Service Department personnel of what inspections and/or diagnosis toperform, prior to replacing and returning a turbocharger to the WPC.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10118254 at NHTSANHTSA communication ID: 10118233
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10118233 at NHTSANHTSA communication ID: 10137665
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin explains the Road Force balancers and what they can do for customer concerns.
Source components: EQUIPMENT.
Source record 10137665 at NHTSANHTSA communication ID: 10137600
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels.
Source components: WHEELS.
Source record 10137600 at NHTSANHTSA communication ID: 10137680
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides information regarding the normal characteristic of instrument panel red brake light intermittently comes on.
Source components: PARKING BRAKE.
Source record 10137680 at NHTSANHTSA communication ID: 10137601
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on engine surfaces.
Source components: ENGINE.
Source record 10137601 at NHTSANHTSA communication ID: 10137605
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.
Source components: EQUIPMENT.
Source record 10137605 at NHTSANHTSA communication ID: 10137679
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary information bulletin provides information to the customer that the rear vision camera only shows 3/4 of the radio display screen and is a normal characteristic in which no parts are to be replaced for this condition.
Source components: BACK OVER PREVENTION: SENSING SYSTEM: CAMERA.
Source record 10137679 at NHTSANHTSA communication ID: 10137653
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin explains the difference in oil filters and the possibilities of what may happen using the incorrect filter.
Source components: ENGINE · EQUIPMENT.
Source record 10137653 at NHTSANHTSA communication ID: 10137640
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
Source components: POWER TRAIN:AUTOMATIC TRANSMISSION.
Source record 10137640 at NHTSANHTSA communication ID: 10137635
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
Source components: EQUIPMENT · FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS.
Source record 10137635 at NHTSANHTSA communication ID: 10137602
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides the dealership with how to prep a vehicle for delivery to the customer to aid in higher CSi scores.
Source components: EQUIPMENT.
Source record 10137602 at NHTSANHTSA communication ID: 10137603
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information on required operating procedures.
Source components: EQUIPMENT.
Source record 10137603 at NHTSANHTSA communication ID: 10118903
NHTSA source summary · Original PDF not reviewed by Recallfolio
16186 - Emission Recall. General Motors has decided to conduct a Voluntary Emission Recall on certain vehicles equipped with a 1.8L engine. On some vehicles, cracking of ceramic components internal to the catalytic converter may occur as a result of higher than anticipated exhaust temperatures. If this occurs, the catalytic converter low efficiency diagnostic will set and the malfunction indicator lamp will illuminate. Dealers are to reprogram the engine control module with calibrations that prevent higher than expected exhaust temperatures.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10118903 at NHTSANHTSA communication ID: 10113978
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides information on Dealer Empowerment Labor Operations and Customer Enthusiasm.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10113978 at NHTSANHTSA communication ID: 10113878
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on. Technician will find Diagnostic Trouble Code P0341 and or P0366 set. If the technician has duplicated the concern replace the related Camshaft Position sensor and retest for the code. If the Diagnostic Trouble Code returns technician should check the history to see if the vehicle was in a collision. If the vehicle has been in a collision technician should call General Motors Technical Assistance Center.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10113878 at NHTSANHTSA communication ID: 10114027
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Non-Design Intent Wheel Lock Nuts and Lug Nuts.
Source components: WHEELS:LUGS/NUTS/BOLTS/STUDS.
Source record 10114027 at NHTSANHTSA communication ID: 10113993
NHTSA source summary · Original PDF not reviewed by Recallfolio
this informational bulletin provides Information on Using MyBuick, MyCadillac, MyChevrolet, and MyGMC Phone Applications to Control GM Accessory Remote Start Kits.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10113993 at NHTSANHTSA communication ID: 10114048
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114048 at NHTSANHTSA communication ID: 10113977
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on proper use of floor mats.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10113977 at NHTSANHTSA communication ID: 10114052
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides a diagnostic tip for technicians who may find an oil leak after a recent oil change has been performed.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114052 at NHTSANHTSA communication ID: 10113976
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides policy information on the requirements for battery testing and warranty replacements.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10113976 at NHTSANHTSA communication ID: 10113857
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that have excessive oil consumption, blue smoke from the exhaust, or a Malfunction Indicator Lamp. Technician should inspect the PVC orifice for leaking oil or drawing a vacuum at idle. If the PCV orifice external port is leaking oil or vacuum, replace the camshaft cover assembly. Technician will inspect for a missing intake manifold Non Return Valve that may have damaged the PCV orifice diaphragm. Check for the return valve if it is not visible use a long cotton swab to wipe any excess oil from the valve to validate. If the non return valve is still not visible, then intake manifold removal for inspection is required to validate. When the valve is present reinstall the intake manifold. When the valve is not present replace the intake manifold assembly.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10113857 at NHTSANHTSA communication ID: 10138086
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operations.
Source components: SUSPENSION.
Source record 10138086 at NHTSANHTSA communication ID: 10138076
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on Normal Characteristic - Delayed Gridline Operation on Initial Start Up
Source components: ELECTRICAL SYSTEM.
Source record 10138076 at NHTSANHTSA communication ID: 10138019
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information for the GM of Canada OnStar Cellular Communication Upgrade to 3G/4G LTE for vehicles that may need an upgrade.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10138019 at NHTSANHTSA communication ID: 10138087
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary information bulletin provides information for diagnosing a power steering fluid leak at the fluid reservoir.
Source components: STEERING.
Source record 10138087 at NHTSANHTSA communication ID: 10138060
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10138060 at NHTSANHTSA communication ID: 10126022
NHTSA source summary · Original PDF not reviewed by Recallfolio
16139 - Special Coverage. On certain vehicles, a P0171 Fuel System Lean or P0101 Mass Air Flow (MAF) Sensor Performance diagnostic trouble code may set as a result of a cracked air cleaner outlet duct. Dealers are to replace the air cleaner outlet duct as necessary. The repairs will be made at no charge to the customer.
Source components: EQUIPMENT.
Source record 10126022 at NHTSANHTSA communication ID: 10138025
NHTSA source summary · Original PDF not reviewed by Recallfolio
This technical bulletin provides a procedure inspecting for excess grease or Sealant on the Exterior of the steering gear due to seeing grease or sealant on certain locations on the gear.
Source components: STEERING.
Source record 10138025 at NHTSANHTSA communication ID: 10138054
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on On rare occasions, a security code input message with SPS error code E5659, M5304, and/or M5530 may be displayed in TIS2web when the technician is programming any module. If this concern is encountered, the technician should start by ensuring that the module being programmed is not a used module and that the VIN matches on VIN plate, TIS2web programming screen, and GDS2 module identification information screen.
Source components: ELECTRICAL SYSTEM.
Source record 10138054 at NHTSANHTSA communication ID: 10138053
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information for automatic transmission Oil Cooler Flush and flow test.
Source components: POWER TRAIN.
Source record 10138053 at NHTSANHTSA communication ID: 10138014
NHTSA source summary · Original PDF not reviewed by Recallfolio
This information bulletin explains the labor operation numbers used for submitting warranty claims and how to setup, and reprogram modules.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10138014 at NHTSANHTSA communication ID: 10116589
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information for dealers how to submit a product information report.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10116589 at NHTSANHTSA communication ID: 10113463
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a check engine light. Technician will find Diagnostic Trouble Code P0446. Technician will need to replace the Evaporative Emissions System canister if spider nesting in the fresh air inlet port.
Source components: ENGINE · EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10113463 at NHTSANHTSA communication ID: 10113456
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10113456 at NHTSANHTSA communication ID: 10116638
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin contains information on Embedded TuneIn App Does Not Function Correctly After Updating TuneIn App on Phone due to newer TuneIn software levels (on the customers phone) no longer supporting embedded automotive applications.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10116638 at NHTSANHTSA communication ID: 10113454
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to help the dealership technicians perform a parasitic drain test for the OnStar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar system.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10113454 at NHTSANHTSA communication ID: 10116637
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Informational bulletin outlines the recommendations for aluminum and chrome wheel refinishing.
Source components: WHEELS.
Source record 10116637 at NHTSANHTSA communication ID: 10113475
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that may have a rough idle or misfire. Technician may find Diagnostic Trouble Code P0300 set in the Engine Control Module. Technician will need to utilize engine controls schematics to compare the Fuel Injector Control Circuit wire colors to determine if the wires are reversed. If this concern is found, inspect the related harnesses and terminals for signs damage due to the misrouting and repair.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING · FUEL SYSTEM, GASOLINE.
Source record 10113475 at NHTSA