2022 Volkswagen
ID.4Problems & recalls

On May 16, 2024, the Office of Defects Investigations (ODI) opened Recall Query (RQ) RQ24010 to investigate the remedy and scope of recalls 23V-213 and 23V-312. The affected vehicles by these recalls included model years (MY) 2021 through 2023 Volkswagen ID.4 vehicles. ODI received reports of the vehicle’s doors opening while the vehicle was in motion post recall remedy. ODI, also, received similar allegations on vehicles that were outside the scope of the recalls. Volkswagen issued recall 23V-213 on March 29, 2023, and recall 23V-213 on May 03, 2023. These recalls addressed the defect of water ingress into the circuit board assembly of the door handle. Water ingress can cause communication issues between the door handle and the door control until. This malfunction resulted in the vehicle door inadvertently opening while the vehicle was in motion. Over the course of the investigation, ODI received 17 unique VIN VOQ complaints of the vehicle doors opening while the vehicle was in motion occurring either post recall remedy or on a vehicle that was outside the recall scope. Volkswagen submitted 190 unique VIN complaints reporting the same circumstances. On September 4, 2024, Volkswagen submitted recall 24V-651 to address the issue of inadvertent opening of the door while the vehicle is in motion. The scope of this recall expands the affected vehicles to include all MY2021-2024 Volkswagen ID.4 models, including those remedied under the subject recalls. The recall remedy consists of replacement of the door handle assembly on all four doors as well as a software update. The software update is performed to update the door handle parameters. The new door handle will have the membrane relocated to the back of the handle to avoid standing water within the handle. Also, a protective coating will be on the front and back of the circuit board to avoid direct moisture formation. In view of the action being taken by Volkswagen, Recall 24V-651, ODI is closing this Recall Query. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Recorded closure: Nov 4, 2024

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

Recorded closure: Aug 7, 2023

Campaign reference in the source: 22V063000