2009 Toyota HIGHLANDER Manufacturer communications & TSBs.Page 3
Original record summaries, dates and identifiers for this model-year. Records 201–292 of 292, ordered newest first. Dated records on this page: Jan 18, 1991–Mar 31, 2014.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Mar 31, 2014Service Bulletin/Repair Instructions
LSC BST Phase 1.
NHTSA communication ID: 10133779
NHTSA source summary · Original PDF not reviewed by Recallfolio
On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smart Stop technology on March 31, 2014., for the following models:
NHTSA source summary · Original PDF not reviewed by Recallfolio
As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake pedal at certain speeds and in certain driving conditions.
NHTSA source summary · Original PDF not reviewed by Recallfolio
On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smart Stop technology on March 31, 2014., for the following models:
Source components: VEHICLE SPEED CONTROL · VEHICLE SPEED CONTROL:ACCELERATOR PEDAL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake pedal at certain speeds and in certain driving conditions.
Source components: SERVICE BRAKES, HYDRAULIC · VEHICLE SPEED CONTROL · VEHICLE SPEED CONTROL:ACCELERATOR PEDAL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Prior to installing remanufactured U660 and U760 transaxles, it is necessary to remove the lower oil cooler tube union from the original transaxle case and install it into the reman unit. A NEW O-ring and printed installation instructions are supplied in separate bag with the reman unit. An instruction tag is also affixed to the unit.
NHTSA source summary · Original PDF not reviewed by Recallfolio
The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. If the operator attempts to ready-on or start the vehicle while there is tension on the steering lock actuator, it will not be able to fully disengage when the "ENGINE START STOP" or "POWER" switch is depressed. This condition will cause the "ENGINE START STOP" or "POWER" switch's LED to flash green and the vehicle will fail to ready-on or start.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer complains of Bluetooth connectivity concerns such as: Difficulty to pair phone, Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the customer's phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone data/settings recently.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Engine No Start and/or Poor Engine Power DTCs set immediately after performing service on the Inverter such as SSC D0M for IPM replacement or Inverter Assembly installation.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles (160 km) at speeds less than 55 mph (90 km/h) with little or no damage to the tire.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
NHTSA source summary · Original PDF not reviewed by Recallfolio
On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the second phase of a Limited Service Campaign to install Smart Stop Technology on December 11, 2013 for the following models
NHTSA source summary · Original PDF not reviewed by Recallfolio
On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the second phase of a Limited Service Campaign to install Smart Stop Technology on December 11, 2013 for the following models:
NHTSA source summary · Original PDF not reviewed by Recallfolio
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Toyota may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in severe occupant injuries. Seat covers are an integral part of this safety system. Replacing fabric seat covers with non-Toyota leather or other seat cover materials may compromise the effectiveness of this safety system. The design of the seat is complex, integrating safety and strength with comfort and luxury. Toyota strongly discourages modifying original equipment seats that have optional side airbags. Additionally, Toyota strongly advises against the installation or use of aftermarket seat covers, which could impair the performance of the side airbags in the event of an accident.
NHTSA source summary · Original PDF not reviewed by Recallfolio
These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone data/settings recently.
Source components: ELECTRICAL SYSTEM · EQUIPMENT:ELECTRICAL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1AR-FE or 2AR-FE engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair procedure below to address this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
NHTSA source summary · Original PDF not reviewed by Recallfolio
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
NHTSA source summary · Original PDF not reviewed by Recallfolio
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the Brake Pedal Force Gauge. Refer to the appropriate Repair Manual for parking brake pedal travel inspection and adjustment specification.
NHTSA source summary · Original PDF not reviewed by Recallfolio
The customer (individual requiring the extender) must visit a Toyota dealership to have the required measurements made and to complete the Seat Belt Extender Worksheet. The worksheet will allow the proper fitting and selection of a Seat Belt Extender for the customer. The dealership personnel should then determine the applicable part number and place an order through Dealer Daily
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2008 ? 2013 model year Highlander vehicles equipped with the 5-speed automatic transaxle may exhibit a whine noise from the final drive gear assembly. This noise is noticeable above 35 mph. Please refer to the repair procedure to address this condition.
Source components: BACK OVER PREVENTION · POWER TRAIN.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: THERE IS A WHINING NOISE WHEN VEHICLE IS DRIVEN ABOVE 35 MPH, FROM FINAL DRIVE GEAR ASSEMBLY AND A REPAIR PROCEDURE HAS AVAILABLE TO ADDRESS THIS ISSUE. MODEL 2008-2013 HIGHLANDER. *PE
Source components: POWER TRAIN:AUTOMATIC TRANSMISSION · STEERING:GEAR BOX (OTHER THAN RACK AND PINION).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some vehicles may exhibit a MIL ?ON? Diagnostic Trouble Code (DTC) P0138 and/or P0158 (Oxygen Sensor Circuit High Voltage Bank 1 or 2). In some instances a P2195 or P2197 (A/F Sensor Signal Stuck Lean) DTC may also be present. This condition may be caused by incorrect Air Fuel Ratio Sensor response. Additionally, a P0606 (ECM/PCM Processor) DTC may be present due to incorrect Oxygen Sensor operation. The following repair procedures should be used to properly diagnose and repair this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: UPDATED INFORMATION REGARDING THE RESPONSE OF THE AIR FUEL RATIO SENSOR, THAT IS INCORRECT AND ALSO, AN INCORRECT OXYGEN SENSOR OPERATION MAY BE PRESENT, DUE TO ECM/PCM PROCESSOR P0606 DTC. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
As communicated in mid-June 2013, the Federal Court in Orange County, California continued the Fairness Hearing regarding the proposed settlement of the consolidated Economic Loss Class Actions related to claims of unintended acceleration until July 19, 2013.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does not close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases where the Power Back Door does close, a pop or clunk noise may also be heard when the back door latch reaches the striker during the power close function.
Source components: ELECTRICAL SYSTEM · LATCHES/LOCKS/LINKAGES:DOORS:LATCH.
NHTSA source summary · Original PDF not reviewed by Recallfolio
The Federal Court in Orange County, CA today continued a Fairness Hearing regarding the proposed settlement of the consolidated Economic L:oss Class Actions relating to claims of unintended acceleration. The new (continued) date for Fairness Hearing is July 19,2013. After the hearing TMS will provide further updates on the status and timing of the settlement.
NHTSA source summary · Original PDF not reviewed by Recallfolio
On June 14, 2013 the Federal Court in Orange County, California will conduct a Fairness Hearing regarding the proposed settlement of the consolidated Economic Loss Class Actions. Dealerships may notice media coverage of this Fairness Hearing.
Source components: VEHICLE SPEED CONTROL · VEHICLE SPEED CONTROL:ACCELERATOR PEDAL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guidelines outlined in this bulletin to ensure proper label application.
NHTSA source summary · Original PDF not reviewed by Recallfolio
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield/rear glass area.
Source components: BACK OVER PREVENTION · STRUCTURE:EMERGENCY:ESCAPE/EGRESS/EXIT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
In mid-April 2013 Toyota will be mailing an update to the Owner's Manual for 2008 through 2012 Model Year Highlander and Highlander HV. Sample Owner labels are provided below for your reference.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING THE UPDATED OWNER'S MANUAL FOR CERTAIN VEHICLES. MODELS 2008-2012 HIGHLANDER. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1AR-FE or 2AR-FE engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair procedure below to address this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: ON CERTAIN VEHICLES, A KNOCK OR RATTLE NOISE, COMING FROM ENGINE COMPARTMENT, IS HEARD DURING A COLD SOAK STARTUP, AND THE CONDITION LASTS APPROXIMATELY ONE SECOND. MODEL YEARS 2009-2012 CAMRY, HIGHLANDER, SIENNA, VENZA, RAV4. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: THERE IS A KNOCKING OR RATTLING NOISE COMING FROM ENGINE COMPARTMENT, FOR A SHORT PERIOD OF TIME, AFTER A COLD SOAK STARTUP. MODEL 2010-2012 CAMRY, 2009-2013 HIGHLANDER, VENZA, 2009-2012 RAV4, 2011-2013 SIENNA. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off.
NHTSA source summary · Original PDF not reviewed by Recallfolio
The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side.
Source components: STEERING: STEERING WHEEL/HANDLE BAR.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2008 ? 2013 model year Highlander and Highlander HV vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering wheel left or right. A new intermediate shaft has been developed to address this condition. Use the following repair procedure to remove and replace the steering intermediate shaft.
Source components: STEERING: STEERING WHEEL/HANDLE BAR.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. This bulletin details the applicable specifications for these systems.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This communication pertains to a current safety recall being conducted by the Southeast Toyota Distributors LLC (SET). TMS is sending this communication for informational purposes in the event you are contacted by a customer covered by this recall.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the TIS and the CUW.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devices did not perform as expected, please follow the steps in the recommendations section below.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does no close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases where the Power Back Door does not close, a pop or clunk noise may also be heard when the back door latch reaches the striker during the power close function.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles (160 km) at speeds less than 55 mph (90 km/h) with little or no damage to the tire.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY CAUSE OIL TO LEAK FROM THE VVT-I OIL HOSE PRODUCING ABNORMAL ENGINE NOISE AND THE OIL PRESSURE LIGHT TO ILLUMINATE. *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE · POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: WHEN OPERATING THE FRONT SIDE WINDOW GLASS THERE MAY BE A RATTLE OR POPPING NOISE. THE WINDOW MAY ALSO BE INOPERATIVE DUE TO DAMAGED WINDOW MOUNTING TABS. 2008-2010 HIGHLANDER. *RM UPDATED 8/10/12. *PE
Source components: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: BRIEF ENGINE KNOCK/RATTLE NOISE COLD STARTUP. IMMEDIATELY FOLLOWING A COLD SOAK STARTUP, SOME MODEL VEHICLES EQUIPPED WITH THE 1AR-FE AND 2AR-FE ENGINES MAY EXHIBIT A BRIEF KNOCK/RATTLE NOISE FROM THE ENGINE COMPARTMENT FOR APPROXIMATELY ONE SECOND. *PE UPDATED 9/28/11. *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. MODEL YEARS FROM 2001-2011. *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: UPDATE TO LOAD CARRYING CAPACITY MODIFICATION. ADDENDUM LABEL WAS INSTALLED AT VEHICLE PROCESSING CENTER WHEN ACCESSORIES WERE INSTALLED. THE ADDENDUM LABEL MUST BE INSTALLED WHEN ACCESSORIES ARE INSTALLED WHICH EXCEED 1.5% OF THE GROSS VEHICLE WEIGHT RATING (GVWR) OR 100 LBS, WHICHEVER IS LESS, ON OR BEFORE THE FIRST RETAIL SALE. CSC LETTER WAS REC'D. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE · POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER VEHICLE HAS COLD SOAKED IN SUBFREEZING AMBIENT AIR TEMPERATURES. *PE UPDATED 9/23/09. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: SOME VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A TICKING/CLICKING TYPE NOISE FROM THE CYLINDER HEAD COVER AREA WHICH MAY BE ACCOMPANIED BY A MIL ON AND ONE OR MORE VVT-I RELATED DIAGNOSTIC TROUBLE CODES (DTCS). *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Toyota customers who find it necessary to increase the length of their seat belts may obtain Seat Belt Extenders at no cost through their local Toyota dealer. The extender is available in 6-inch, 9-inch, 12-inch, 15-inch, and 18-inch lengths. The extender is available only in black. Owners are informed of the Seat Belt Extender availability through the Owner's Manual included in each vehicle