2005 Kia
SEDONAProblems & recalls

TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.

Components: EXTERIOR LIGHTING · STRUCTURE. Confirm detailed applicability in the original document.

PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.

Components: ENGINE AND ENGINE COOLING. Confirm detailed applicability in the original document.

TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.

Components: EQUIPMENT ADAPTIVE/MOBILITY · EQUIPMENT:MECHANICAL. Confirm detailed applicability in the original document.

TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?

Components: EQUIPMENT ADAPTIVE/MOBILITY · LATCHES/LOCKS/LINKAGES. Confirm detailed applicability in the original document.

TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cables, including; * Electrical interference and limited or no functionality when attempting to play music, or when charging a device through the USB port * Excessive static or noise when listening to the audio source * Malfunctions and screen freeze of the head unit screen * Slow down of the system response while device is plugged in * Music will not play from iPhone 5 or 6 with Kia iPod cable and aftermarket adapter * No or limited functionality when trying to play music from an Apple device

Components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY. Confirm detailed applicability in the original document.

TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL, THEN REFERENCE THE AUTOMATIC TRANSAXLE SYSTEM/ REPAIR PROCEDURES/ INSPECTION AND ADJUSTMENT SECTION FOR THE CORRECT ATF CHECK/FILL PROCEDURES.

Components: POWER TRAIN. Confirm detailed applicability in the original document.

KIA: INTERMITTENT MIL ON WITH NO FAULT CODE STORED; INFORMATION ABOUT DTC P1330. PROVIDES INFORMATION RELATING TO CERTAIN VEHICLES. IN AFFECTED VEHICLES AN INTERMITTENT SHORT TO GROUND IN A CIRCUIT ONLY INTENDED FOR TESTING PURPOSES MAY CAUSE THE MIL TO ILLUMINATE AND A DTC P1330 (SPARK TIMING ADJUST) TO BE STORED. *PE

Components: ENGINE AND ENGINE COOLING:ENGINE. Confirm detailed applicability in the original document.

KIA: ECM UPGRADE WITH TP SENSOR REPLACEMENT-MIL ON WITH DTC P2135/P0638. INFORMATION RELATED TO ECM SOFTWARE AND TP SENSOR UPGRADE ON SOME VEHICLES WITH 2.7L ENGINES WHICH MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH THE ELECTRONIC THROTTLE CONTROL (ETC) SYSTEM RELATED DTC P2135 OR P0638 OR P2A00 OR P2A03. *PE

Components: ELECTRICAL SYSTEM:SOFTWARE · ENGINE AND ENGINE COOLING:ENGINE. Confirm detailed applicability in the original document.

KIA: POWER SLIDING DOOR REMOE CONTROLLER MOTOR REPLACEMENT. ON SOME VEHICLES, A POWER SLIDING DOOR (PSD) MAY NOT OPEN WHEN USING AN OVERHEAD CONSOLE SWITCH, B PILLAR SWITCH OR REMOTE CONTROL BUTTON. *PE

Components: ELECTRICAL SYSTEM · STRUCTURE:BODY:DOOR. Confirm detailed applicability in the original document.

KIA: INCREASED STEERING EFFORT. IN AREAS WHERE HEAVY ROAD SALT USE OCCURS, INCREASED STEERING EFFORT AND NOISE (FROM STEERING INTERMEDIATE SHAFT) FOR SOME SEDONA. *PE

Components: STEERING. Confirm detailed applicability in the original document.

KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE

Components: EXTERIOR LIGHTING:BRAKE LIGHTS · EXTERIOR LIGHTING:TAIL LIGHTS · PARKING BRAKE:INDICATOR LIGHT. Confirm detailed applicability in the original document.

SEDONA (GQ) CORRODED HEATER COOLANT PIPES - ON SOME BUILT FROM MAY 1, 2001, TO AUG. 30, 2005. *NJ UPDATED 6/17/08. *NJ

Components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. Confirm detailed applicability in the original document.