The manufacturer’s record · Page 1 of 3
Original record summaries, dates and identifiers for this model-year. Records 1–100 of 211, ordered newest first. Dated records on this page: May 11, 2021–Jul 9, 2026.
Back to 2018 Jeep CHEROKEE problems & recallsThis archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
NHTSA communication ID: 11035039
NHTSA source summary · Original PDF not reviewed by Recallfolio
Stop/Start Illuminated, 0x22 During Fork Wear Routine Technicians may experience the following: SYMPTOM: ● Negative response 0X22 after Recall 01C flash triggers one or more communication codes with controllers.
Source components: ELECTRICAL SYSTEM · ENGINE.
Source record 11035039 at NHTSANHTSA communication ID: 11035038
NHTSA source summary · Original PDF not reviewed by Recallfolio
Unable to Complete 01C Recall Drive Cycle C14A7-97 Active Technicians may experience the following: SYMPTOM: ● After performing Recall 01C, the vehicle may get a 'Service AWD' message on the EVIC.
Source components: POWER TRAIN.
Source record 11035038 at NHTSANHTSA communication ID: 11034385
NHTSA source summary · Original PDF not reviewed by Recallfolio
Backup Camera Poor Image Quality Inspection
Source components: STRUCTURE:BODY.
Source record 11034385 at NHTSANHTSA communication ID: 11031688
NHTSA source summary · Original PDF not reviewed by Recallfolio
Door Latch, Handle And Ajar Additional Service Information.
Source components: ELECTRICAL SYSTEM · STRUCTURE:BODY.
Source record 11031688 at NHTSANHTSA communication ID: 11031328
NHTSA source summary · Original PDF not reviewed by Recallfolio
Two Speed Power Transfer Unit Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set the following Diagnostic Trouble Code (DTC): ? C1494-07 - PTU Fork Position-Mechanincal Failures. Customers m
Source components: POWER TRAIN.
Source record 11031328 at NHTSANHTSA communication ID: 11031348
NHTSA source summary · Original PDF not reviewed by Recallfolio
(XX1) Two Speed Power Transfer Unit (PTU) - Select 2017 - 2019 Jeep Cherokee (KL)
Campaign / software reference: ID-26-22 Middle East & Africa
Source components: POWER TRAIN.
Source record 11031348 at NHTSANHTSA communication ID: 11031347
NHTSA source summary · Original PDF not reviewed by Recallfolio
(XX1) Two Speed Power Transfer Unit (PTU) - Select 2017 - 2019 Jeep Cherokee (KL)
Campaign / software reference: ID-26-20 APAC
Source components: POWER TRAIN.
Source record 11031347 at NHTSANHTSA communication ID: 11031346
NHTSA source summary · Original PDF not reviewed by Recallfolio
(XX1) Two Speed Power Transfer Unit (PTU) - Select 2017 - 2019 Jeep Cherokee (KL)
Campaign / software reference: ID-26-21
Source components: POWER TRAIN.
Source record 11031346 at NHTSANHTSA communication ID: 11031345
NHTSA source summary · Original PDF not reviewed by Recallfolio
(XX1) Two Speed Power Transfer Unit (PTU) - Select 2017 - 2019 Jeep Cherokee (KL)
Campaign / software reference: ID-26-21 Enlarged Europe
Source components: POWER TRAIN.
Source record 11031345 at NHTSANHTSA communication ID: 11031344
NHTSA source summary · Original PDF not reviewed by Recallfolio
ID-26-19 (XX1) Two Speed Power Transfer Unit (PTU) - Select 2017 - 2019 Jeep Cherokee (KL)
Campaign / software reference: ID-26-19
Source components: POWER TRAIN.
Source record 11031344 at NHTSANHTSA communication ID: 11031343
NHTSA source summary · Original PDF not reviewed by Recallfolio
D-26-10 (XX1) Two Speed Power Transfer Unit (PTU) - Select 2017 - 2019 Jeep Cherokee (KL)
Campaign / software reference: D-26-10
Source components: POWER TRAIN.
Source record 11031343 at NHTSANHTSA communication ID: 11031327
NHTSA source summary · Original PDF not reviewed by Recallfolio
Two Speed Power Transfer Unit Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set the following Diagnostic Trouble Code (DTC): ? C1494-07 - PTU Fork Position-Mechanincal Failures. Customers m
Source components: POWER TRAIN.
Source record 11031327 at NHTSANHTSA communication ID: 11030035
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 11030035 at NHTSANHTSA communication ID: 11028904
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 11028904 at NHTSANHTSA communication ID: 11026812
NHTSA source summary · Original PDF not reviewed by Recallfolio
Service 4wd Light On, AWD System Service Required Message Illuminated. Diagnostic Trouble Code (DTC) C14A7-97 PTU Motor Component Or System Operation Obstructed Or Blocked.
Source components: POWER TRAIN.
Source record 11026812 at NHTSANHTSA communication ID: 11026652
NHTSA source summary · Original PDF not reviewed by Recallfolio
Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only
Source components: ELECTRICAL SYSTEM.
Source record 11026652 at NHTSANHTSA communication ID: 11022011
NHTSA source summary · Original PDF not reviewed by Recallfolio
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
Source components: STRUCTURE:BODY.
Source record 11022011 at NHTSANHTSA communication ID: 11022027
NHTSA source summary · Original PDF not reviewed by Recallfolio
Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.
Source components: UNKNOWN OR OTHER.
Source record 11022027 at NHTSANHTSA communication ID: 11022026
NHTSA source summary · Original PDF not reviewed by Recallfolio
Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.
Source components: UNKNOWN OR OTHER.
Source record 11022026 at NHTSANHTSA communication ID: 11022012
NHTSA source summary · Original PDF not reviewed by Recallfolio
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
Source components: STRUCTURE:BODY.
Source record 11022012 at NHTSANHTSA communication ID: 11022003
NHTSA source summary · Original PDF not reviewed by Recallfolio
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates
Source components: STRUCTURE:BODY.
Source record 11022003 at NHTSANHTSA communication ID: 11020600
NHTSA source summary · Original PDF not reviewed by Recallfolio
Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed
Source components: ELECTRICAL SYSTEM.
Source record 11020600 at NHTSANHTSA communication ID: 11018447
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Washer Light On And Will Not Turn Off After Adding Washer Solvent."
Source components: ELECTRICAL SYSTEM.
Source record 11018447 at NHTSANHTSA communication ID: 11015810
NHTSA source summary · Original PDF not reviewed by Recallfolio
"CANISTER Vapor -If an issue is detected with the Evaporative System Integrity Module (ESIM) Detector and not the Vapor Canister, only replace the ESIM Detector. -Before replacing the Vapor Canister due to Hard to Fill condition, replicate the condition at the Gas Station. If the condition is replicated, then check: 1) for kinked or pinched Clean Air Hose between the ESIM and the EVAP Air Filter; 2) for plugged EVAP Air Filter; 3) for kinked or pinched Vapor Hose between the Fuel Tank and the Vapor Canister. If the EVAP Filter is restricted, the replace the Filter. -Check if the Vapor Canister is flooded with fuel or the Recirculation Line has fuel. If fuel is found in the Vapor Canister or the Recirculation Line, then drop the Fuel Tank, remove the FDM Lock Ring to check if the internal Vapor Line is properly connected to the FDM Port. If the Vapor Line is not connected, then drain the fuel from the internal Vapor Line and properly connect to the FDM. Replace the Vapor Canister and the ESIM."
Source components: UNKNOWN OR OTHER.
Source record 11015810 at NHTSANHTSA communication ID: 11013171
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 11013171 at NHTSANHTSA communication ID: 11012884
NHTSA source summary · Original PDF not reviewed by Recallfolio
Door Latch, Handle And Ajar Additional Service Information.
Source components: STRUCTURE:BODY.
Source record 11012884 at NHTSANHTSA communication ID: 11012777
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 11012777 at NHTSANHTSA communication ID: 11012010
NHTSA source summary · Original PDF not reviewed by Recallfolio
FUEL VAPOR CANISTER FILTER EVAP Fuel Filters are to be checked for restriction / blockage on a regular schedule as indicated in the Owner s Manual. If the Filter is restricted or blocked then replace the part. For customers that drive light duty trucks in extreme dusty and dirty road conditions, please reference information only TSB 25-009-24 for an available MOPAR Dual EVAP Filter kit that is customer paid.
Source components: UNKNOWN OR OTHER.
Source record 11012010 at NHTSANHTSA communication ID: 11006983
NHTSA source summary · Original PDF not reviewed by Recallfolio
"2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: ● Oil pressure low indicator lamp illumination between oil changes. ● Excessive oil consumption. This bulletin involves performing an oil consumption verification test and possibly replacing the long block."
Source components: ENGINE.
Source record 11006983 at NHTSANHTSA communication ID: 11005320
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels."
Source components: STRUCTURE:BODY.
Source record 11005320 at NHTSANHTSA communication ID: 11002828
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "
Source components: ELECTRICAL SYSTEM · ENGINE.
Source record 11002828 at NHTSANHTSA communication ID: 11000172
NHTSA source summary · Original PDF not reviewed by Recallfolio
SWITCH - BRAKE
Source components: ELECTRICAL SYSTEM · SERVICE BRAKES.
Source record 11000172 at NHTSANHTSA communication ID: 10251783
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10251783 at NHTSANHTSA communication ID: 10247452
NHTSA source summary · Original PDF not reviewed by Recallfolio
Service 4wd Light On, AWD System Service Required Message Illuminated. Diagnostic Trouble Code (DTC) C14A7-97 PTU Motor Component Or System Operation Obstructed Or Blocked, Set.
Source components: AIR BAGS · ENGINE AND ENGINE COOLING.
Source record 10247452 at NHTSANHTSA communication ID: 10244356
NHTSA source summary · Original PDF not reviewed by Recallfolio
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
Source components: SUSPENSION.
Source record 10244356 at NHTSANHTSA communication ID: 10248509
NHTSA source summary · Original PDF not reviewed by Recallfolio
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
Source components: ELECTRICAL SYSTEM.
Source record 10248509 at NHTSANHTSA communication ID: 10248508
NHTSA source summary · Original PDF not reviewed by Recallfolio
Rain Sensor Before replacing the rain sensor during a front windshield replacement inspect the part for part numbers. If you have part numbers; 68507366, 68483780, 68384226 or 68384225, these parts do not utilize a replaceable gel pad, only replace the sensor for a missing or damaged gel pad. For part numbers 68298334, 68298468, 68607452 or 68194700 the gel pad should be replaced during all windshield replacements and can be ordered through MOPAR, complete sensor replacement is not necessary. Contact: FCA Redacted Content for further questions If no response in 15 minutes, proceed with repair.
Source components: VISIBILITY:WINDSHIELD WIPER/WASHER.
Source record 10248508 at NHTSANHTSA communication ID: 10244348
NHTSA source summary · Original PDF not reviewed by Recallfolio
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
Source components: ELECTRICAL SYSTEM:WIRING.
Source record 10244348 at NHTSANHTSA communication ID: 10244347
NHTSA source summary · Original PDF not reviewed by Recallfolio
Rain Sensor Before replacing the rain sensor during a front windshield replacement inspect the part for part numbers. If you have part numbers; 68507366, 68483780, 68384226 or 68384225, these parts do not utilize a replaceable gel pad, only replace the sensor for a missing or damaged gel pad. For part numbers 68298334, 68298468, 68607452 or 68194700 the gel pad should be replaced during all windshield replacements and can be ordered through MOPAR, complete sensor replacement is not necessary. Contact: FCA Redacted Content for further questions If no response in 15 minutes, proceed with repair.
Source components: VISIBILITY:WINDSHIELD WIPER/WASHER.
Source record 10244347 at NHTSANHTSA communication ID: 10243209
NHTSA source summary · Original PDF not reviewed by Recallfolio
FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10243209 at NHTSANHTSA communication ID: 10243208
NHTSA source summary · Original PDF not reviewed by Recallfolio
Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10243208 at NHTSANHTSA communication ID: 10242779
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification ZD7 - Radio Software update
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10242779 at NHTSANHTSA communication ID: 10242717
NHTSA source summary · Original PDF not reviewed by Recallfolio
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10242717 at NHTSANHTSA communication ID: 10241056
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification ZD7 - Radio Software Update
Source components: ELECTRICAL SYSTEM · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10241056 at NHTSANHTSA communication ID: 10240002
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification ZD7 - Radio Software Update
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10240002 at NHTSANHTSA communication ID: 10239957
NHTSA source summary · Original PDF not reviewed by Recallfolio
Water Quality When Mixed With Engine Coolant
Source components: ENGINE AND ENGINE COOLING.
Source record 10239957 at NHTSANHTSA communication ID: 10236933
NHTSA source summary · Original PDF not reviewed by Recallfolio
wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
Source components: ENGINE AND ENGINE COOLING · EQUIPMENT.
Source record 10236933 at NHTSANHTSA communication ID: 10236928
NHTSA source summary · Original PDF not reviewed by Recallfolio
2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: ? Oil pressure low indicator lamp illumination between oil changes. ? Excessive oil consumption. This bulletin involves performing an oil consumption verification test and possibly replacing the long block.
Source components: ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION · UNKNOWN OR OTHER.
Source record 10236928 at NHTSANHTSA communication ID: 10247906
NHTSA source summary · Original PDF not reviewed by Recallfolio
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
Source components: ENGINE AND ENGINE COOLING.
Source record 10247906 at NHTSANHTSA communication ID: 10234379
NHTSA source summary · Original PDF not reviewed by Recallfolio
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
Source components: ENGINE AND ENGINE COOLING.
Source record 10234379 at NHTSANHTSA communication ID: 10247905
NHTSA source summary · Original PDF not reviewed by Recallfolio
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
Source components: BACK OVER PREVENTION.
Source record 10247905 at NHTSANHTSA communication ID: 10234420
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 10234420 at NHTSANHTSA communication ID: 10234378
NHTSA source summary · Original PDF not reviewed by Recallfolio
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
Source components: ENGINE AND ENGINE COOLING.
Source record 10234378 at NHTSANHTSA communication ID: 10247995
NHTSA source summary · Original PDF not reviewed by Recallfolio
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
Source components: STRUCTURE.
Source record 10247995 at NHTSANHTSA communication ID: 10234468
NHTSA source summary · Original PDF not reviewed by Recallfolio
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
Source components: STRUCTURE.
Source record 10234468 at NHTSANHTSA communication ID: 10231800
NHTSA source summary · Original PDF not reviewed by Recallfolio
2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: Oil pressure low indicator lamp illumination between oil changes. Excessive oil consumption. This bulletin involves performing an oil consumption verification test and possibly replacing the long block.
Source components: EXTERIOR LIGHTING · SERVICE BRAKES.
Source record 10231800 at NHTSANHTSA communication ID: 10231750
NHTSA source summary · Original PDF not reviewed by Recallfolio
Warranty Bulletin D-23-01 - (XB1) 2.4L Engine ? Select 2014 - 2019 Jeep Cherokee (KL), 2017 - 2018 Jeep Compass (MP), 2015 - 2018 Jeep Renegade (FWD/AWD) (BU), 2013 - 2016 Dodge Dart (PF), 2015 - 2017 Chrysler 200 (UF), 2016 - 2018 Fiat 500X (FWD) (FB), (AWD), 2015 - 2018 Ram Promaster City (VM)
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10231750 at NHTSANHTSA communication ID: 10231711
NHTSA source summary · Original PDF not reviewed by Recallfolio
Washer Light On And Will Not Turn Off After Adding Washer Solvent.
Source components: EQUIPMENT:ELECTRICAL.
Source record 10231711 at NHTSANHTSA communication ID: 10229810
NHTSA source summary · Original PDF not reviewed by Recallfolio
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Digital imaging pre authorization is required for Smart Warranty Base dealers or Pre Approval is required from Regional Office depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
Source components: STRUCTURE.
Source record 10229810 at NHTSANHTSA communication ID: 10229804
NHTSA source summary · Original PDF not reviewed by Recallfolio
2.4L Engine Oil Consumption Test The customer may comment that the vehicles engine oil level is low or they need to add oil between oil change intervals and no visible signs of oil leaking from the engine. This bulletin involves performing an oil consumption verification test.
Source components: ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION: OIL COOLER.
Source record 10229804 at NHTSANHTSA communication ID: 10229572
NHTSA source summary · Original PDF not reviewed by Recallfolio
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
Source components: STRUCTURE.
Source record 10229572 at NHTSANHTSA communication ID: 10225424
NHTSA source summary · Original PDF not reviewed by Recallfolio
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
Source components: STRUCTURE.
Source record 10225424 at NHTSANHTSA communication ID: 10225287
NHTSA source summary · Original PDF not reviewed by Recallfolio
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
Source components: STRUCTURE · STRUCTURE:INTERIOR PANELS:DOOR · UNKNOWN OR OTHER.
Source record 10225287 at NHTSANHTSA communication ID: 10230301
NHTSA source summary · Original PDF not reviewed by Recallfolio
Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed
Source components: ELECTRICAL SYSTEM · TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS.
Source record 10230301 at NHTSANHTSA communication ID: 10223765
NHTSA source summary · Original PDF not reviewed by Recallfolio
Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed
Source components: ELECTRICAL SYSTEM.
Source record 10223765 at NHTSANHTSA communication ID: 10214585
NHTSA source summary · Original PDF not reviewed by Recallfolio
A Rattle Or Creak Noise Is Heard From The Dual Pane Sunroof Area.
Source components: EQUIPMENT · VISIBILITY:SUN/MOON ROOF ASSEMBLY.
Source record 10214585 at NHTSANHTSA communication ID: 10228064
NHTSA source summary · Original PDF not reviewed by Recallfolio
UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10228064 at NHTSANHTSA communication ID: 10227983
NHTSA source summary · Original PDF not reviewed by Recallfolio
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
Source components: ENGINE AND ENGINE COOLING · EQUIPMENT.
Source record 10227983 at NHTSANHTSA communication ID: 10229059
NHTSA source summary · Original PDF not reviewed by Recallfolio
No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting
Source components: ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM).
Source record 10229059 at NHTSANHTSA communication ID: 10223097
NHTSA source summary · Original PDF not reviewed by Recallfolio
No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting
Source components: POWER TRAIN.
Source record 10223097 at NHTSANHTSA communication ID: 10220715
NHTSA source summary · Original PDF not reviewed by Recallfolio
No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting
Source components: ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM · UNKNOWN OR OTHER.
Source record 10220715 at NHTSANHTSA communication ID: 10212318
NHTSA source summary · Original PDF not reviewed by Recallfolio
No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting
Source components: ELECTRICAL SYSTEM.
Source record 10212318 at NHTSANHTSA communication ID: 10229041
NHTSA source summary · Original PDF not reviewed by Recallfolio
Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10229041 at NHTSANHTSA communication ID: 10223079
NHTSA source summary · Original PDF not reviewed by Recallfolio
Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off
Source components: EQUIPMENT:ELECTRICAL.
Source record 10223079 at NHTSANHTSA communication ID: 10220697
NHTSA source summary · Original PDF not reviewed by Recallfolio
Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off
Source components: ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER · UNKNOWN OR OTHER.
Source record 10220697 at NHTSANHTSA communication ID: 10212300
NHTSA source summary · Original PDF not reviewed by Recallfolio
Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off
Source components: ELECTRICAL SYSTEM.
Source record 10212300 at NHTSANHTSA communication ID: 10229122
NHTSA source summary · Original PDF not reviewed by Recallfolio
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC):P06EF - Engine Restart Performance. Customers may experience the following:Long engine crank after an Engine Stop/Start (ESS) event.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING · EXTERIOR LIGHTING.
Source record 10229122 at NHTSANHTSA communication ID: 10223160
NHTSA source summary · Original PDF not reviewed by Recallfolio
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC):P06EF - Engine Restart Performance. Customers may experience the following:Long engine crank after an Engine Stop/Start (ESS) event.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING · EXTERIOR LIGHTING.
Source record 10223160 at NHTSANHTSA communication ID: 10220778
NHTSA source summary · Original PDF not reviewed by Recallfolio
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC):P06EF - Engine Restart Performance. Customers may experience the following:Long engine crank after an Engine Stop/Start (ESS) event.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING · EXTERIOR LIGHTING.
Source record 10220778 at NHTSANHTSA communication ID: 10212381
NHTSA source summary · Original PDF not reviewed by Recallfolio
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC):P06EF - Engine Restart Performance. Customers may experience the following:Long engine crank after an Engine Stop/Start (ESS) event.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING · EQUIPMENT ADAPTIVE/MOBILITY · POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM).
Source record 10212381 at NHTSANHTSA communication ID: 10222964
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification W20 Reprogram Powertrain Control Module
Source components: POWER TRAIN.
Source record 10222964 at NHTSANHTSA communication ID: 10224601
NHTSA source summary · Original PDF not reviewed by Recallfolio
Powertrain Control Module.
Source components: POWER TRAIN.
Source record 10224601 at NHTSANHTSA communication ID: 10218507
NHTSA source summary · Original PDF not reviewed by Recallfolio
Media Device Connection Guidelines For Bluetooth, Apple CarPlay, Android Auto Or USB To The Radio Head Unit
Source components: EQUIPMENT:ELECTRICAL.
Source record 10218507 at NHTSANHTSA communication ID: 10218443
NHTSA source summary · Original PDF not reviewed by Recallfolio
DIFFERENTIAL, Rear Axle (KL 4WD w/DK2 = 1-SPEED RDM) The Differential, Rear Axle (aka RDM) design, pump design, Driveline Control Module (aka DLCM) hardware & software and pressure sensor have all changed in the past few years. The changes are not interchangeable and each had a separate implementation date. Please comprehend it to avoid repeat repairs. There are 2 sections each with 3 sub-sections: 1) For 2014/5 VINs with DK2 = 1-spd RDM 2) For 2016 and later VINs with DK2 = 1-spd RDM 1) For 2014/5 VINs with DK2 = 1-spd RDM 2014 - 2015 VINs were built with a 1-speed RDM used a 24 plate clutch design. New service RDMs 68550586A$ use a 20-plate design. 1.1) If replacing the RDM · 24 plate and 20-plate design RDMs are NOT interchangeable unless the Drive Line Control Module (DLCM) is also replaced. · 68550586A$ service RDMs have a 20 clutch plate design · Not all 20-plate RDMs have the new pump design. The new pump requires a new DLCM. · All new service RDMs are shipped with the new pump design. · If a new 68550586AA service RDMs is installed, then replace the DLCM with new DLCM 68540647AA - 1-spd designed for the 20-plate RDM. 1.2) If replacing the DLCM but not the RDM or pump assembly, then · If the RDM is the original 24 plate design then use 68540645AA - 1-spd, 24 plate DLCM AND replace the pump with 68551790AA · If the RDM is the new 20 plate design then use 68540647AA - 1-spd, 20 plate DLCM AND also replace the pump with 68551790AA new pump unless the RDM previously had a 68551790AA installed. 1.3) If replacing the pump assembly, then use 68551790AA (new pump) AND also replace the DLCM with the version that matches the correct version of the RDM (24 or 20 plate). · Use 68540645AA for the 24 plate RDM with a new pump. · Use 68540647AA for the 20 plate RDM with a new pump. 2) For 2016 and later VINs with DK2 = 1-spd RDM Early 2016 were built with 68090612AG 24 plate RDMs. Use Section 1 ?For 2014/5 VINs with DK2 = 1-spd RDM? to resolve. The balance of M
Source components: BACK OVER PREVENTION · ELECTRICAL SYSTEM · ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC) · FUEL SYSTEM, GASOLINE · SERVICE BRAKES, HYDRAULIC.
Source record 10218443 at NHTSANHTSA communication ID: 10218442
NHTSA source summary · Original PDF not reviewed by Recallfolio
DIFFERENTIAL, Rear Axle (KL 4WD w/DK4 = 2-SPEED RDM) The Differential, Rear Axle (aka RDM) design, pump design, Driveline Control Module (aka DLCM) hardware & software and pressure sensor have all changed in the past few years. The chages are not interchangeable and each had a separate implementation date. Please comprehend it to avoid repeat repairs. There are 2 sections each with 3 sub-sections: 1) For 2014/5 VINs with DK2 = 1-spd RDM 2) For 2016 and later VINs with DK2 = 1-spd RDM 1) For 2014/5 VINs with DK4 = 2-spd RDM 2014 - 2015 VINs built with a 2-speed RDM used a 24 plate clutch design. Service RDMs (DK4: 68545100AA and DK4 + AWL: 68545101AA) have a 20-plate design. 1.1) If replacing the RDM · 24-plate and 20-plate design RDMs are NOT interchangeable unless the Drive Line Control Module (DLCM) is also replaced. · Both 68545100A$ and 68545101A$ service RDMs have a 20 clutch plate design · Not all 20 plate RDMs have the new pump design. The new pump requires a new DLCM. · All new service RDMs are shipped with the new pump design. · If a new 20 plate service RDM is installed, then replace the DLCM with new DLCM 68383660AE - 2-spd designed for the 20 plate RDM. 1.2) If replacing the DLCM but not the RDM or pump assembly, then · If the RDM is the original 24 plate design then use 68540646AA - 2-spd, 24 plate DLCM AND also replace the pump with 68551790AA new pump. · If the RDM is the new 20 plate design then use 68383660AE - 2-spd, 20 plate DLCM AND also replace the pump with 68551790AA new pump unless the RDM previously had a 68551790AA installed. 1.3) If replacing the pump assembly, then use 68551790AA (new pump) AND also replace the DLCM with the version that matches the correct version of the RDM (24 or 20 plate). · Use 68540646AA for the 24-plate RDM with a new pump. · Use 68383660AE for the 20-plate RDM with a new pump. 2) Early 2016 were built with 24 plate RDMs. These include p/n?s 68090615AJ (2spd std), and 52123642AJ (2spd locker). Use Secti
Source components: BACK OVER PREVENTION · ELECTRICAL SYSTEM · ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC) · FUEL SYSTEM, GASOLINE · SERVICE BRAKES, HYDRAULIC.
Source record 10218442 at NHTSANHTSA communication ID: 10219992
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Click Noise at Low Speed Turns
Source components: BACK OVER PREVENTION.
Source record 10219992 at NHTSANHTSA communication ID: 10230183
NHTSA source summary · Original PDF not reviewed by Recallfolio
No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
Source components: ELECTRICAL SYSTEM.
Source record 10230183 at NHTSANHTSA communication ID: 10221597
NHTSA source summary · Original PDF not reviewed by Recallfolio
No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
Source components: ELECTRICAL SYSTEM.
Source record 10221597 at NHTSANHTSA communication ID: 10230180
NHTSA source summary · Original PDF not reviewed by Recallfolio
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
Source components: ENGINE AND ENGINE COOLING.
Source record 10230180 at NHTSANHTSA communication ID: 10221594
NHTSA source summary · Original PDF not reviewed by Recallfolio
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
Source components: ENGINE AND ENGINE COOLING.
Source record 10221594 at NHTSANHTSA communication ID: 10221334
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Seat Side Shield Updated Service Procedure This bulletin informs the technician that when either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified. The technician will need to know the following: When either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified.
Source components: SEATS.
Source record 10221334 at NHTSANHTSA communication ID: 10212508
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Seat Side Shield Updated Service Procedure This bulletin informs the technician that when either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified. The technician will need to know the following: When either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified.
Source components: EQUIPMENT · SEAT BELTS.
Source record 10212508 at NHTSANHTSA communication ID: 10221277
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Complaint May Include Engine Oil Leak Or Consumption
Source components: ENGINE AND ENGINE COOLING.
Source record 10221277 at NHTSANHTSA communication ID: 10212473
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Complaint May Include Engine Oil Leak Or Consumption
Source components: ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION.
Source record 10212473 at NHTSANHTSA communication ID: 10221228
NHTSA source summary · Original PDF not reviewed by Recallfolio
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Redacted Content
Source components: ELECTRICAL SYSTEM:WIRING.
Source record 10221228 at NHTSANHTSA communication ID: 10230139
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Seat Side Shield Updated Service Procedure This bulletin informs the technician that when either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified. The technician will need to know the following: When either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified.
Source components: SEAT BELTS.
Source record 10230139 at NHTSANHTSA communication ID: 10223501
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Seat Side Shield Updated Service Procedure This bulletin informs the technician that when either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified. The technician will need to know the following: When either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified.
Source components: SEAT BELTS · SEAT BELTS:FRONT.
Source record 10223501 at NHTSANHTSA communication ID: 10223367
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Seat Side Shield Updated Service Procedure This bulletin informs the technician that when either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified. The technician will need to know the following: When either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified.
Source components: SEATS.
Source record 10223367 at NHTSANHTSA communication ID: 10198461
NHTSA source summary · Original PDF not reviewed by Recallfolio
Front Seat Side Shield Updated Service Procedure This bulletin informs the technician that when either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified. The technician will need to know the following: When either of the front seat side shields are replaced the buckle will need to be replaced as well. If only the buckle needs to be replaced the front seat side shield will need to be modified.
Source components: EQUIPMENT · STRUCTURE.
Source record 10198461 at NHTSANHTSA communication ID: 10230029
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Complaint May Include Engine Oil Leak Or Consumption
Source components: ENGINE.
Source record 10230029 at NHTSA