2025 Ford EXPLORER Manufacturer communications & TSBs.Page 2
Original record summaries, dates and identifiers for this model-year. Records 101–182 of 182, ordered newest first. Dated records on this page: May 18, 2024–Jul 15, 2025.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Jul 15, 2025Service Bulletin/Repair Instructions
SSM 54051
NHTSA communication ID: 11020887
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024-2025 Nautilus, 2025 Explorer/Aviator/Expedition/Navigator vehicles may occasionally require a hard reset of the Ford/Lincoln Digital Experience system. To perform a hard reset, press and release the volume button on the center console 5 times within 7 seconds. Some vehicles with older level software may require the volume button to be pressed and held for at least 5 seconds. The Owners Manual is in process of being updated with this information.
Source components: ELECTRICAL SYSTEM · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2023-2025 Explorer (rear windows only), Bronco Sport, Escape, and Maverick vehicles equipped with minor feature code B2DAC may exhibit an inoperative passenger front and/or rear window. To confirm a vehicle is built with a certain minor feature code, review the build information by clicking "Additional Information" under Vehicle Information or double-clicking the vehicle identification number (VIN) in the upper left corner of Professional Technician System (PTS). This may be due to an open diode in the window switch. To correct the condition, replace the window switch of the affected window. If the condition persists continue with normal diagnostics. Refer to Workshop Manual, Section 501-11. For claiming, use causal part 14529 and labor operation 14529A in the Service Labor Time Standards (SLTS) Manual.
Source components: ELECTRICAL SYSTEM · VISIBILITY/WIPER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer vehicles equipped with a 2.3L EcoBoost engine may require removal of the turbocharger oil return tube due to various concerns. Workshop Manual, Section 303-04 has been updated with improved turbocharger oil return tube removal and installation service procedure steps.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer Active/Police Interceptor® Utility/Expedition/Navigator/Nautilus vehicles may exhibit diagnostic trouble codes (DTCs) B1A01:01, B1A02:01, B1A03:01, B1A04:01, B1A05:01 and/or B1A06:01 in the audio front control module (ACM) with no customer symptoms. This condition does not affect vehicle durability and no additional diagnosis or service is required.
Source components: ELECTRICAL SYSTEM · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2021-2025 F-150 non-Lightning, 2023-2025 F-Super Duty, 2024-2025 Ranger, and 2025 Explorer vehicles may exhibit a perceived improper functioning fog lamp(s). Customers may describe fog lamps blinking, turning on or off, or flashing. If the vehicle is equipped with cornering lamps, this may be normal function. Under certain conditions and inputs, either lamp might turn on or off independently to aid visibility during cornering. This condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. For additional cornering lamp information, refer to the Owner's Manual and/or Workshop Manual (WSM), Section 417-01.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some of the vehicles listed in the Model statement above may exhibit driver assistance feature warning messages displayed in the instrument panel cluster (IPC). Additionally, some modules may store invalid data/lost communication diagnostic trouble codes (DTCs). This may be due to software in the image processing module A (IPMA).
Source components: FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This article supersedes TSB 25-2157 to add a customer symptom. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate Auto hold, auto start-stop, and/or defrost button LED indicators inoperative This may be due to the APIM (accessory protocol interface module) software.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Quality improvements include: -Robustness action to ensure Diagnostic Trouble Codes are being set correctly. -Prevents a network communication error that may cause an error message in the center screen
Campaign / software reference: ECG-25.2.8.4.1
Source components: ELECTRICAL SYSTEM · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2020-2023 Explorer/Aviator, 2020-2025 Police Interceptor Utility, 2020-2022 Escape/Corsair, and 2022-2024 Maverick vehicles equipped with a hybrid powertrain may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450:00 stored in the powertrain control module (PCM). This may be due to an evaporative emission system concern or may also be caused by the customer overfilling the fuel tank. If this condition occurs, perform normal diagnosis per Workshop Manual (WSM) Section, 303-13 and repair as necessary. Inform the customer that the condition may have been caused by overfilling of the fuel tank and to not top-off the fuel tank when the fuel pump nozzle automatically shuts off for the first time. Refer the customer to the Fuel and Refueling section of their Owner Manual for additional information.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco Sport/E-Series/Escape/Corsair/Expedition/Navigator/Explorer/Aviator/F-150/F-Super Duty/Mustang/Ranger, and 2022-2025 Maverick vehicles may require an A/C compressor clutch assembly replacement be performed for various concerns. Workshop Manual (WSM), Section 412-00 Removal and Installation has been updated to eliminate the need to remove and install the A/C compressor to change out the A/C Compressor clutch assembly.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2023-2025 Escape vehicles equipped with a 1.5L/2.0L EcoBoost engine, 2023-2025 Corsair vehicles equipped with a 2.0L EcoBoost engine, 2024-2025 Nautilus vehicles equipped with a 2.0L EcoBoost engine, 2024-2025 Mustang vehicles with a 2.3L EcoBoost engine, and 2025 Bronco/Explorer/Ranger vehicles equipped with a 2.3L EcoBoost engine may exhibit an engine misfire condition with diagnostic trouble codes (DTC) P0301, P0302, P0303 and/or P0304 set in the powertrain control module (PCM). This may be due to the spark plugs and/or ignition coils. To correct the condition, refer to Workshop Manual (WSM), Section 303-07 for normal diagnostics.
NHTSA source summary · Original PDF not reviewed by Recallfolio
2025 Explorer/Police Interceptor Utility non-hybrid vehicles built on or after 05-Mar-2025 and 2025 Aviator vehicles built on or after 24-Apr-2025 are no longer equipped with the passenger side underbody air deflector. The vehicle is not misbuilt. Do not submit a claim for this condition.
Source components: FUEL/PROPULSION SYSTEM · VEHICLE SPEED CONTROL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024-2025 Nautilus, 2025 Explorer/Aviator/Expedition/Navigator vehicles may occasionally require a hard reset of the Ford/Lincoln Digital Experience system. To perform a hard reset, press and release the volume button on the center console 5 times within 7 seconds. Some Nautilus vehicles with older level software, may require the volume button to be pressed and held for at least 5 seconds. The Owners Manual is in process of being updated with this information.
Source components: ELECTRICAL SYSTEM · UNKNOWN OR OTHER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer/Aviator vehicles may exhibit driver assistance feature warning messages displayed in the instrument panel cluster (IPC). Additionally, some modules may store invalid data/lost communication diagnostic trouble codes (DTCs). The image processing module A (IPMA) should not store these DTCs. This condition may be due to the software in the IPMA causing no communication on the network. To restore communication/function, download and run the "IPMA - Image Processing Module A (IPMA) Recovery" app in the Ford Diagnosis and Repair System (FDRS) tool, then "Trusted Real-Time Operation Network (TRON) Module Authentication" following FDRS screen instructions. Next, download and run the "IPMA - Image Processing Module A (IPMA) Alignment" app, recheck DTCs and confirm that all warning messages are cleared from the IPC. For vehicles equipped with a 360 degree camera, perform the "360 Degree View Camera Alignment" procedure in Workshop Manual (WSM), Section 413-13. If these steps correct the condition, release the vehicle back to the customer.
Source components: BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING · ELECTRICAL SYSTEM · UNKNOWN OR OTHER · VISIBILITY/WIPER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
This article supersedes TSB 25-2121 to update the affected production build dates. Some of the vehicles listed in the Model statement above may exhibit a click/pop noise while turning the steering wheel from straight ahead to full lock during low speed turning events. This noise may be due to front upper strut mount washer movement under steering loads.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
NHTSA source summary · Original PDF not reviewed by Recallfolio
After replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occurring between modules and/or a module is not responding. This may be a result of missing the new module secret authentication security key obtained when running the Ford Diagnosis and Repair System (FDRS) "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure after replacement. When replacing a TRON capable module, run the FDRS "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure in the GWM tool box, not in the toolbox of the module with the DTC's, to distribute a new set of secret authentication security keys to all TRON-capable modules. Using the specific vehicle identification number (VIN), refer to Workshop Manual (WSM), Section 418-00 and 418-01 for updated DTCs, applicable TRON module listings and pinpoint tests.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate This may be Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Inbound call cannot be heard Wireless charger icon inaccurate This may be due to the APIM (accessory protocol interface module) software due to the APIM (accessory protocol interface module) software.
NHTSA source summary · Original PDF not reviewed by Recallfolio
After replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occuring between modules and/or a module is not responding. This may be a result of missing the new module secret authentication security key obtained when running the Ford Diagnosis and Repair System (FDRS) "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure after replacement. When replacing a TRON capable module, run the FDRS "Trusted Real-Time Operation Network (TRON) Module Authentication" procedure to distribute a new set of secret authentication security keys to all TRON-capable modules. Using the specific VIN, refer to Workshop Manual (WSM), Section 418-00 and 418-01 for updated DTCs, applicable TRON module listings and pinpoint tests.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2020-2023 Explorer/Aviator, 2020-2025 Police Interceptor Utility, 2020-2025 Escape/Corsair, 2022-2025 Maverick, and 2024-2025 Nautilus vehicles equipped with a hybrid powertrain may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2450:00 stored in the powertrain control module (PCM). This may be due to an evaporative emission system concern or may also be caused by the customer overfilling the fuel tank. If this condition occurs, perform normal diagnosis per Workshop Manual (WSM) Section, 303-13 and repair as necessary. Inform the customer that the condition may have been caused by overfilling of the fuel tank and to not top-off the fuel tank when the fuel pump nozzle automatically shuts off for the first time. Refer the customer to the Fuel and Refueling section of their Owner Manual for additional information.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024-2025 Explorer vehicles built on 01-Feb-2024 and through 31-Jul-2024 may exhibit a rattle/clunk/knock noise from the front suspension at low speeds between 8-30 mph (13-48 km/h) over bumpy or uneven pavement while driving straight.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some of the vehicles listed in the Model statement above may exhibit a click/pop noise while turning the steering wheel from straight ahead to full lock during low speed turning events. This noise may be due to front upper strut mount washer movement under steering loads.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2020-2025 Explorer/Aviator vehicles equipped with a 3.0L EcoBoost engine may require removal of the left turbocharger oil supply tube due to various concerns.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer vehicles built on or before 27-Nov-2024 may exhibit driver power door lock and auto start stop system inoperative with diagnostic trouble code (DTC) P166B in the gear shift module (GSM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P008A and/or P0420 stored in the powertrain control module (PCM) and no other driveability symptoms present. This may be due to the software level of the PCM.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Certain 2024 Model Year F-150, Mustang, Expedition, Navigator, Transit, Super Duty, and 2025 Model Year Explorer vehicles, equipped a 10R80/10R100 Transmission. Transmission Assembly Replacement
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Quality improvements include: -Addresses a false DTC caused by a software bug -Robustness action to reduce Key off load battery drain caused by the Controller Area Network bus staying awake"
Campaign / software reference: 25-OTA GSM-25.8.10 Explorer
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer vehicles equipped with a 2.3L EcoBoost and 2025 Bronco Sport/Maverick vehicles equipped with a 2.0L EcoBoost may not be compatible with state emissions testing equipment if that equipment has not been updated to be compatible with the new testing protocols.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer Active/Police Interceptor® Utility vehicles may exhibit diagnostic trouble codes (DTCs) B1A01:01, B1A02:01, B1A03:01, B1A04:01, B1A05:01 and/or B1A06:01 in the audio control module (ACM) with no customer symptoms.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2023-2025 Explorer/Aviator vehicles equipped with the 3.0L EcoBoost engine and up to 15,000 miles (24,140 km) may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P219A (Bank 1 Air-Fuel Ratio Imbalance) and/or P219B (Bank 2 Air-Fuel Ratio Imbalance) stored in the powertrain control module (PCM) with no effect on vehicle operation.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2017-2025 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2018-2024 F-150/Edge, 2018 MKX, 2019-2023 Nautilus, 2020-2025 Explorer/Aviator, 2021-2024 Bronco, and 2024 Ranger vehicles equipped with a 2.7L or a 3.0L EcoBoost engine may exhibit an engine oil leak from the crankshaft rear seal with retaining plate.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024-2025 Nautilus and 2025 Explorer/Aviator vehicles may exhibit a concern where during an inbound phone call the person in the vehicle cannot be heard.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2023-2025 Escape/Corsair vehicles equipped with a 1.5L or 2.0L EcoBoost engine, 2024 Mustang vehicles equipped with a 2.3L EcoBoost engine, 2024-2025 Nautilus, and 2025 Explorer vehicles equipped with a 2.3L EcoBoost engine may exhibit an engine misfire condition with diagnostic trouble codes (DTC) P0301, P0302, P0303 and/or P0304 set in the powertrain control module (PCM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer/Aviator vehicles built on or before 15-Oct-2024 with a 2.3L/3.0L EcoBoost engine may exhibit an engine over-temperature warning displayed in the IPC and an illuminated MIL with DTC P1299 along with P2C38 or P2C39 stored in the PCM.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer vehicles built on 16-May-2024 and through 25-Jun-2024 may exhibit inoperative steering wheel switches located on both sides of the steering wheel.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer vehicles, excluding Police Interceptor® Utility, built on or before 04-Nov-2024 may exhibit a powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0929:77 stored in the gear shift module (GSM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer Active/Police Interceptor Utility vehicles may exhibit diagnostic trouble codes (DTCs) B1A01:01, B1A02:01, B1A03:01, B1A04:01, B1A05:01 and/or B1A06:01 in the audio control module (ACM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2018-2024 F150/Edge, 2018 MKX, 2019-2023 Nautilus, 2020-2025 Explorer/Aviator, 2021-2024 Bronco, and 2024 Ranger vehicles equipped with a 2.7L EcoBoost or a 3.0L EcoBoost engine may exhibit an engine oil leak from the crankshaft rear seal with retaining plate.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer vehicles equipped with a 2.3L EcoBoost engine may exhibit an illuminated MIL and/or powertrain malfunction (wrench) indicator. DTC P060A:75 and/or P0607:45 may be stored in the PCM with no other driveability symptoms.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some of the following vehicles may exhibit one passive key that is unable to start the vehicle or activate the passive entry feature; however, all remote keyless entry (RKE) physical button functionality works correctly and the second passive key will have full/correct functionality (including being able to start the vehicle):
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer XLT/Police Interceptor Utility vehicles may exhibit diagnostic trouble codes (DTCs) B1A01:01, B1A02:01, B1A03:01, B1A04:01, B1A05:01 and/or B1A06:01 in the audio control module (ACM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2020-2025 Police Interceptor Utility hybrid vehicles may exhibit multiple warning messages, various driveability concerns and/or an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P061B stored in the powertrain control module (PCM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
In some of the affected vehicles, the ABS Electronic Brake Booster may keep the electronic communication system awake, causing battery drain, potentially resulting in a no-start condition. Additionally, the ABS malfunction indicator lamp may illuminate improperly.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer 2.3L vehicles may exhibit a failure to communicate with state emissions testing equipment due to equipment that has not been updated to be compatible with the new testing protocols.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024 Bronco Sport/Escape and 2025 Explorer vehicles may have been ordered with a DIO Securicode® RKE wired keypad that requires installation and enabling by the dealer prior to delivery.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2023-2025 Explorer/Aviator vehicles equipped with the 3.0L EcoBoost engine and up to 15,000 miles (24,140 km) may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P219A (Bank 1 Air-Fuel Ratio Imbalance) and/or P219B (Bank 2 Air-Fuel Ratio Imbalance) stored in the powertrain control module (PCM) with no effect on vehicle operation.
NHTSA source summary · Original PDF not reviewed by Recallfolio
2025 Explorer/Aviator Built On Or Before 14-Jun-2024, 2024 Nautilus - Map Is Blank Or Map Feature Is Inoperative When Vehicles Equipped with Google Automotive Services (Minor Feature Code HKCGA And IEPAT)
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024-2025 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit an illuminated malfunction indicator (MIL) lamp with engine over-temperature warning in the message center and poor air conditioning (A/C) performance from the engine cooling fan not running.
NHTSA source summary · Original PDF not reviewed by Recallfolio
2025 Explorer/Aviator vehicles equipped with Vapor Blue (Explorer)/Whisper Blue Metallic (Aviator) exterior paint are equipped with a Titanium engine compartment and under hood finish, which may appear to be primer or unfinished.
NHTSA source summary · Original PDF not reviewed by Recallfolio
2025 Explorer vehicles equipped with Vapor Blue exterior paint are equipped with a Titanium engine compartment and under hood finish, which may appear to be primer or unfinished.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024 Bronco Sport/Escape and 2025 Explorer vehicles may have been ordered with a DIO Securicode® RKE wired keypad that requires installation and enabling by the dealer prior to delivery.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2020-2025 Explorer/Aviator vehicles may have a concern where the second row outboard manual/power seats do not fold, exhibit excess effort to fold, or do not slide forward/backward easily. Power or manual second row seats must be pushed forward manually during easy entry function since the assist spring will reduce but not eliminate manual effort. Refer to the Owner's Manua
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer/Aviator/Police Interceptor vehicles may exhibit a flashing powertrain malfunction (wrench) indicator while in transport mode with diagnostic trouble code (DTC) P112A stored in the powertrain control module (PCM). This may be due to excessive engine starts while the vehicle is in transport mode
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024 Nautilus and 2025 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit a symptom where the vehicle's right (passenger) exterior mirror does not come out of the folded position after the vehicle is unlocked. This may be due to a software concern within the driver's door module (DDM) and passenger's door module (PDM). If the mirror unfolds after pressing the mirror fold button in the vehicle twice, inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in Q4 2024. Replacement or reprogramming of the DDM and PDM will not resolve this condition at this time.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer/Aviator/Police Interceptor Utility vehicles may set diagnostic trouble code (DTC) U211B:87 in the headlamp control module (HCM) when a diagnostic self-test is performed. This may be due to a HCM communication error within a specified timeframe. DTC U211B:87 does not affect vehicle durability with no effect on vehicle operation and no additional diagnostics or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in Q3 2024. Replacement or reprogramming of the HCM will not resolve this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2024 Nautilus and 2025 Explorer/Police Interceptor Utility vehicles may exhibit a symptom where the vehicle's right (passenger) exterior mirror does not come out of the folded position after the vehicle is unlocked. This may be due to a software concern within the driver's door module (DDM) and passenger's door module (PDM)
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2025 Explorer XLT/Police Interceptor Utility vehicles may exhibit diagnostic trouble code (DTCs) B1A01:01, B1A02:01, B1A03:01, B1A04:01, B1A05:01 and/or B1A06:01 in the audio control module (ACM). This may be due a software concern within the ACM. If any of these DTCs are identified but the vehicle does not present any radio functionality concerns, replacement or reprogramming of the ACM will not resolve this condition at this time. Engineering is currently working on a solution and a software update is expected in Q3 2024
NHTSA source summary · Original PDF not reviewed by Recallfolio
2025 Explorer vehicles will exhibit inoperative rear windows when the vehicle is in the delayed accessory power mode. This is normal characteristic operation for this vehicle. The front windows will continue to operate in delayed accessory power. The Workshop Manual (WSM) and Owner's Manual are being updated to reflect this operation. Refer to WSM, Section 501-11 for a description of the delayed accessory power mode
NHTSA source summary · Original PDF not reviewed by Recallfolio
Various vehicles equiped with 10R80/10R80 MHT/10R100/10R140 transmissions may require replacement of the seal kits (7153) when internal repairs are being performed. These kits come with 4 wheel drive (4WD) seals and will no longer include the 2WD seals. When working on a 2WD vehicle, any 2WD seals must be ordered separately. Refer to the parts catalog for the proper 2WD seals required.