The manufacturer’s record · Page 11 of 19
Original record summaries, dates and identifiers for this model-year. Records 1,001–1,100 of 1,848, ordered newest first. Dated records on this page: Oct 16, 2014–Feb 9, 2015.
Back to 2012 Chevrolet VOLT problems & recallsThis archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
NHTSA communication ID: 10113531
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides information to clarify proper transaction administration of GM Dealer Empowerment Program and Goodwill Cases.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10113531 at NHTSANHTSA communication ID: 10113527
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin communicates GM's position on exterior lighting components ?tinted or smoked? by an outside vendor.
Source components: EXTERIOR LIGHTING.
Source record 10113527 at NHTSANHTSA communication ID: 10113519
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin adds the 2015 model year to repair information on correcting a customer concern of poor, limited, reduced Remote Keyless Entry (RKE) or Remote Vehicle Start (RVS) range.
Source components: ELECTRICAL SYSTEM:IGNITION · EQUIPMENT:ELECTRICAL.
Source record 10113519 at NHTSANHTSA communication ID: 10114383
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that may have a engine noise is sometimes louder than expected. Also will explain the known normal and abnormal reasons why the engine may be louder. When the vehicle speed is between 25-50 miles per hour the road noise does not mask the engine noise this is considered normal. When the vehicle is first started for the day the system will perform a catalyst preconditioning for about a minute. At this time the engine will seem louder than normal, this is normal. At times the engine often runs at wide open throttle, but at a reduced speed. This sound is uncharacteristic of a four-cylinder engine in a traditional sedan, but is a characteristic of an extended range electric vehicle such as the Chevrolet Volt. Technician will be able to inspect for abnormal induction ground-out conditions. These locations should be checked lower rubber isolator on air box not installed correctly or missing, upper induction resonator cover not installed properly, refrigerant line not bolted to engine support bracket, and throttle body contacting coolant pipes behind it. Abnormal exhaust ground-out conditions should also be inspected. These locations are at the exhaust clamp rearward of the second catalytic converter is contacting the battery heat shield, exhaust resonator underbody is contacting the heat shield. Repair any abnormal issue found.
Source components: ENGINE AND ENGINE COOLING.
Source record 10114383 at NHTSANHTSA communication ID: 10113514
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin communicates GM's position on use of nitrogen gas in tires.
Source components: TIRES.
Source record 10113514 at NHTSANHTSA communication ID: 10113512
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides a diagnostic tip for low line pressure or pressure regulator valve stuck after transmission service pump cover replacement.
Source components: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR.
Source record 10113512 at NHTSANHTSA communication ID: 10139438
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information to correct a dealer concern of what they perceive to be paint staining when the protective shipping film is removed from certain vehicles.
Source components: EQUIPMENT.
Source record 10139438 at NHTSANHTSA communication ID: 10139437
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
Source components: ELECTRICAL SYSTEM.
Source record 10139437 at NHTSANHTSA communication ID: 10139436
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin adds 2014 - 2015 model years to information regarding comeback prevention and using Customer Concern Verification Sheets (CCVS).
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10139436 at NHTSANHTSA communication ID: 10139433
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on control module diagnostics and configuration, programming using the TIS Service Programming System (SPS), set-up and warranty.
Source components: ELECTRICAL SYSTEM.
Source record 10139433 at NHTSANHTSA communication ID: 10079522
NHTSA source summary · Original PDF not reviewed by Recallfolio
14274 - CUSTOMER SATISFACTION PROGRAM. ON CERTAIN 2010-2015 MODEL YEAR CADILLAC SRX AND 2011-2015 MODEL YEAR CHEVROLET VOLT VEHICLES, THE MANUAL LIFTGATE GAS STRUT MAY DETACH FROM THE LIFTGATE WHEN THE LIFTGATE IS CLOSED AND THE PISTON ROD COULD SEPARATE FROM THE STRUT TUBE. IF THIS OCCURS, THE LIFTGATE WILL NOT WORK AND THERE MAY BE DAMAGE TO THE LIFTGATE EXTERIOR TRIM AND SHEET METAL. DEALERS ARE TO REPLACE THE LIFTGATE STRUTS.
Source components: STRUCTURE:BODY:HATCHBACK/LIFTGATE.
Source record 10079522 at NHTSANHTSA communication ID: 10139430
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on chemical staining, pitting, corrosion and/or spotted appearance of chromed aluminum wheels, along with warranty information regarding these conditions.
Source components: WHEELS.
Source record 10139430 at NHTSANHTSA communication ID: 10114360
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication advises the technician that the Battery Charge Module for the Chevrolet Volt Part Restriction has ended. These parts can now be ordered directly through your parts department without General Motors Technical Assistance Center authorization.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10114360 at NHTSANHTSA communication ID: 10114358
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication advises the technician that the Electronic Brake Control Module and Brake Pressure Modulator Valve part restriction has ended. These parts can now be ordered directly through your parts department without General Motors Technical Assistance Center authorization.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114358 at NHTSANHTSA communication ID: 10114357
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician on the steps to vacuum fill to ensure the cooling system is properly filled. Technician will need to use special tool GE-47716 Vac-N-Fill Coolant Refill Tool. Technician will also perform Hybrid/EV Battery Pack Coolant Pump Bleed Procedure in the GDS2 tool. After performing the GDS2 coolant bleed procedure drive vehicle for approximately 5 miles in a slalom type of situation to purge any remaining air from battery pack cooling plates.
Source components: ENGINE AND ENGINE COOLING.
Source record 10114357 at NHTSANHTSA communication ID: 10095153
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ON THE STEPS TO VACUUM FILL TO ENSURE THE COOLING SYSTEM IS PROPERLY FILLED. TECHNICIAN WILL NEED TO USE SPECIAL TOOL GE-47716 VAC-N-FILL COOLANT REFILL TOOL. TECHNICIAN WILL ALSO PERFORM HYBRID/EV BATTERY PACK COOLANT PUMP BLEED PROCEDURE IN THE GDS2 TOOL. AFTER PERFORMING THE GDS2 COOLANT BLEED PROCEDURE DRIVE VEHICLE FOR APPROXIMATELY 5 MILES IN A SLALOM TYPE OF SITUATION TO PURGE ANY REMAINING AIR FROM BATTERY PACK COOLING PLATES.
Source components: ENGINE AND ENGINE COOLING:COOLING SYSTEM.
Source record 10095153 at NHTSANHTSA communication ID: 10095123
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT THE BATTERY CHARGE MODULE FOR THE CHEVROLET VOLT PART RESTRICTION HAS ENDED. THESE PARTS CAN NOW BE ORDERED DIRECTLY THROUGH YOUR PARTS DEPARTMENT WITHOUT GENERAL MOTORS TECHNICAL ASSISTANCE CENTER AUTHORIZATION.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10095123 at NHTSANHTSA communication ID: 10094941
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT THE ELECTRONIC BRAKE CONTROL MODULE AND BRAKE PRESSURE MODULATOR VALVE PART RESTRICTION HAS ENDED. THESE PARTS CAN NOW BE ORDERED DIRECTLY THROUGH YOUR PARTS DEPARTMENT WITHOUT GENERAL MOTORS TECHNICAL ASSISTANCE CENTER AUTHORIZATION.
Source components: ELECTRICAL SYSTEM · SERVICE BRAKES, AIR.
Source record 10094941 at NHTSANHTSA communication ID: 10139422
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
Source components: ENGINE AND ENGINE COOLING.
Source record 10139422 at NHTSANHTSA communication ID: 10114352
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
Source components: TIRES · WHEELS.
Source record 10114352 at NHTSANHTSA communication ID: 10095317
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT CHANGING THE TIRE AND WHEEL SIZE ON VEHICLES. GENERAL MOTORS WILL ONLY SUPPORT A TIRE CALIBRATION FOR TIRES THAT HAVE BEEN SIZED, TESTED AND DESIGNED FOR THE VEHICLE IN QUESTION AND ITS APPLICATIONS. TECHNICIAN SHOULD NOT USE THE INFORMATION THAT IS PROVIDED BY THE ANTILOCK BRAKING SYSTEM TIRE SIZE SELECTION.
Source components: EQUIPMENT.
Source record 10095317 at NHTSANHTSA communication ID: 10139415
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provides policy information on ACDelco® replacement battery warranty procedures.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10139415 at NHTSANHTSA communication ID: 10139414
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin adds 2012 - 2015 model years to information communicating a change in the product field action customer reimbursement procedure (U.S. Dealers Only).
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10139414 at NHTSANHTSA communication ID: 10114343
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This scenario also includes incoming Bluetooth calls. One type of unwanted call can be made if the key pad is faulty the OnStar system will try to make a blue button call for shorted voltage in the circuits. The OnStar module could have an internal fault and produce a "Phone Unavailable" audio message also it may have a Diagnostic Trouble Code U1500 or B1000. Refer to diagnostics for the Diagnostic Trouble Code making sure to follow any applicable Bulletins or Preliminary Information sheets. A "Ready" or "OnStar ready" audio message heard while driving. In some cases it has been found that the customer is inadvertently pressing the ?push to talk? button on the steering wheel controls. On rare occasions, other issues in the steering column or Steering Wheel Control system may induce this concern.
Source components: EQUIPMENT:ELECTRICAL.
Source record 10114343 at NHTSANHTSA communication ID: 10114342
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
Source components: EQUIPMENT:ELECTRICAL · EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM).
Source record 10114342 at NHTSANHTSA communication ID: 10094888
NHTSA source summary · Original PDF not reviewed by Recallfolio
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. TECHNICIAN WILL NEED TO DETERMINE WHAT TYPE OF CALL THE CUSTOMER IS HAVING THAT IS UNWANTED. THE VEHICLE MAY RECEIVE AN INCOMING CALL JUST LIKE ANY OTHER PHONE. TYPICALLY THE CUSTOMER WILL HEAR THE PHONE RINGING IN THE VEHICLE. THIS SCENARIO ALSO INCLUDES INCOMING BLUETOOTH CALLS. ONE TYPE OF UNWANTED CALL CAN BE MADE IF THE KEY PAD IS FAULTY THE ONSTAR SYSTEM WILL TRY TO MAKE A BLUE BUTTON CALL FOR SHORTED VOLTAGE IN THE CIRCUITS. THE ONSTAR MODULE COULD HAVE AN INTERNAL FAULT AND PRODUCE A PHONE UNAVAILABLE AUDIO MESSAGE ALSO IT MAY HAVE A DIAGNOSTIC TROUBLE CODE U1500 OR B1000. REFER TO DIAGNOSTICS FOR THE DIAGNOSTIC TROUBLE CODE MAKING SURE TO FOLLOW ANY APPLICABLE BULLETINS OR PRELIMINARY INFORMATION SHEETS. A GREADYH OR GONSTAR READYH AUDIO MESSAGE HEARD WHILE DRIVING. IN SOME CASES IT HAS BEEN FOUND THAT THE CUSTOMER IS INADVERTENTLY PRESSING THE PUSH TO TALK BUTTON ON THE STEERING WHEEL CONTROLS. ON RARE OCCASIONS, OTHER ISSUES IN THE STEERING COLUMN OR STEERING WHEEL CONTROL SYSTEM MAY INDUCE THIS CONCERN.
Source components: EQUIPMENT:ELECTRICAL.
Source record 10094888 at NHTSANHTSA communication ID: 10139411
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides information that accessory remote start does not work with OnStar RemoteLink? phone application.
Source components: EQUIPMENT.
Source record 10139411 at NHTSANHTSA communication ID: 10139200
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information that may be useful in diagnosing/testing batteries that have set for a long period of time and/or set in cold weather climates to correct a customer concern of symptoms that include, but not limited to, a slow or no crank condition that may be caused by a discharged battery.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY · ENGINE.
Source record 10139200 at NHTSANHTSA communication ID: 10139199
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.
Source components: SUSPENSION.
Source record 10139199 at NHTSANHTSA communication ID: 10139198
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary informational bulletin provides information that the tire pressure monitor (TPM) sensors must always be re-learned when accessory wheels are installed on the vehicle.
Source components: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS.
Source record 10139198 at NHTSANHTSA communication ID: 10057262
NHTSA source summary · Original PDF not reviewed by Recallfolio
GENERAL MOTORS:2010-2015 CADILLAC SRX, 2011-2015 CHEVROLET VOLT . SOME MODEL VEHICLES ARE EXPERIENCING PROBLEMS WITH THE LIFTGATE STRUT ROD DETACHING. DEALERS ARE TO CORRECT THE PROBLEM. *LJ SEE DOCUMENT SEARCH BUTTON FOR OWNERS LETTER. *LJ
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10057262 at NHTSANHTSA communication ID: 10126251
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin was created for the Manual Transmission Operating Characteristics. The different noises caused by driver habit, weather conditions , and normal manual transmission noises.
Source components: POWER TRAIN.
Source record 10126251 at NHTSANHTSA communication ID: 10114801
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicle that may OnStar inoperative and Navigation/GPS/Compass issues. Technician may find Diagnostic Trouble Codes B101D sym 3C and or F0. Technician will gather data using a scan tool and contact General Motors Technical Assistance Center for further assistance. After approval technician will replace the OnStar module.
Source components: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM).
Source record 10114801 at NHTSANHTSA communication ID: 10126248
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary information bulletin provides information on how to remove stainless steel wheel nut caps with the matching depth of socket used on the wheel nut.
Source components: WHEELS.
Source record 10126248 at NHTSANHTSA communication ID: 10114797
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have heated seats inoperative. Technician may find Diagnostic Trouble Code U0209 in the Heater-Vent-Air Conditioning. Technician will need to reprogram the seat heater control module using Service Programming System with the latest calibration to address the concern.
Source components: ELECTRICAL SYSTEM · SEATS.
Source record 10114797 at NHTSANHTSA communication ID: 10114783
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have heated seats inoperative. Technician may find Diagnostic Trouble Code U0209 in the Heater-Vent-Air Conditioning. Technician will need to reprogram the seat heater control module using Service Programming System with the latest calibration to address the concern.
Source components: ELECTRICAL SYSTEM · SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER.
Source record 10114783 at NHTSANHTSA communication ID: 10114781
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about servicing any of the cooling systems on the these vehicles, which includes the High Voltage Battery Assembly, pumps, reservoirs, hoses, air separators, radiators, PIM, engine or heater system it is important to use the proper coolant and water mixture. The Power Electronics / Charging and Battery Cooling systems require a 50/50 mix of GM DEX-COOL® and de-ionized water.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114781 at NHTSANHTSA communication ID: 10126237
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.
Source components: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM.
Source record 10126237 at NHTSANHTSA communication ID: 10126231
NHTSA source summary · Original PDF not reviewed by Recallfolio
This information provides the proper way to install the floor mats .
Source components: EQUIPMENT.
Source record 10126231 at NHTSANHTSA communication ID: 10114775
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
Source components: ELECTRICAL SYSTEM.
Source record 10114775 at NHTSANHTSA communication ID: 10126221
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty informational bulletin advised the technician that when performing a wiring repair, more information is required.
Source components: ELECTRICAL SYSTEM:WIRING.
Source record 10126221 at NHTSANHTSA communication ID: 10114770
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician the steps to diagnose and repair vehicles that have Check Engine Light illuminated with an "Engine Unavailable" and ?Reduced Propulsion? messages on the Driver Information Center. Technician will find Diagnostic Trouble Code P1B03. Technician should replace Motor 1 Stator.
Source components: ENGINE AND ENGINE COOLING.
Source record 10114770 at NHTSANHTSA communication ID: 10114769
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician the steps to diagnose and repair vehicles that have Check Engine Light illuminated with an "Engine Unavailable" and ?Reduced Propulsion? messages on the Driver Information Center. Technician may find Diagnostic Trouble Codes a P0AB9 and P0AC4. Technician should not clear any Diagnostic Trouble Codes and ensure Global Diagnostic System 2 is up to date. Technician will need to use Global Diagnostic System 2 and check all modules for Diagnostic Trouble Codes. Now use Global Diagnostic System 2 to create freeze frame data from Hybrid Powertrain Control Module and the Engine Control Module and save a report. Technician will need to verify that the vehicle had not been run very low or out of fuel. Also verify the customer did not press the Power Button causing the vehicle to turn off while driving. Verify that the Internal Combustion Engine runs properly and no other engine related or communication related Diagnostic Trouble Codes are present. Technician should inquire if the remote star was used on the last two drive cycles before the Diagnostic Trouble Code set. Technician should update the Engine Control Module if so. Technician should inspect the ground locations G106 (engine block) and G113 (drive unit case) have been cleaned and are secure making sure the ground eyelets do not spin. Technician should also check for past service history for prior mechanical engine or wiring harness repairs. Inspect the cam timing connector and repair any damage.
Source components: ELECTRICAL SYSTEM · ENGINE · POWER TRAIN.
Source record 10114769 at NHTSANHTSA communication ID: 10114763
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician when the vehicle will not charge the high voltage battery, current Diagnostic Trouble Codes, and the vehicle will not shift out of park. Technician will follow Service Information for any current Diagnostic Trouble Codes. Technician will insure the charge cord is working correctly. Verify that the issue was not a result of charging infrastructure. Also monitoring the proximity signal for an improper or noisy signal as called out in the current version of PIP4905 may assist in finding a receptacle concern. Inspect the charge receptacle for cracking or water intrusion. If you find an issue with the charge receptacle, a new updated charge receptacle has been released to address the issues.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY · POWER TRAIN:AUTOMATIC TRANSMISSION.
Source record 10114763 at NHTSANHTSA communication ID: 10114761
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication advises the technician that effective November 1st, 2010 the Drive Motor Generator Control Module part number 24266807 will be placed on restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING.
Source record 10114761 at NHTSANHTSA communication ID: 10114760
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will need to call General Motors Technical Assistance Center for further assistance. If the Diagnostic Trouble Code B101D has a sym 37 set please refer to the latest version of PIC5492.
Source components: ELECTRICAL SYSTEM.
Source record 10114760 at NHTSANHTSA communication ID: 10126211
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary bulletin provides a procedure to reprogram the power steering module to correct the customers concern of the MIL on and a drop in power steering assist.
Source components: STEERING.
Source record 10126211 at NHTSANHTSA communication ID: 10253584
NHTSA source summary · Original PDF not reviewed by Recallfolio
Information on Removal/Cracking of Stainless Steel Wheel Nut Caps.
Source components: WHEELS.
Source record 10253584 at NHTSANHTSA communication ID: 10247716
NHTSA source summary · Original PDF not reviewed by Recallfolio
J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
Source components: ELECTRICAL SYSTEM · EQUIPMENT.
Source record 10247716 at NHTSANHTSA communication ID: 10247061
NHTSA source summary · Original PDF not reviewed by Recallfolio
J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
Source components: ELECTRICAL SYSTEM · ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10247061 at NHTSANHTSA communication ID: 10245938
NHTSA source summary · Original PDF not reviewed by Recallfolio
OnStar Module Does Not Support All B101D Symptom Codes.
Source components: ELECTRICAL SYSTEM.
Source record 10245938 at NHTSANHTSA communication ID: 10073885
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10073885 at NHTSANHTSA communication ID: 10070544
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: ENGINE.
Source record 10070544 at NHTSANHTSA communication ID: 10070504
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL.
Source record 10070504 at NHTSANHTSA communication ID: 10070111
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: STEERING.
Source record 10070111 at NHTSANHTSA communication ID: 10069961
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: ENGINE.
Source record 10069961 at NHTSANHTSA communication ID: 10056835
NHTSA source summary · Original PDF not reviewed by Recallfolio
CADILLAC: WHEN SERVICING ANY OF THE COOLING SYSTEMS ON THE CADILLAC, CHEVROLET &OPEL AMPERA VEHICLES IT IS IMPORTANT TO USE THE PROPER COOLANT AND WATER MIXTURE. *LJ UPDATED 2/25/15. *LJ
Source components: ENGINE AND ENGINE COOLING:COOLING SYSTEM.
Source record 10056835 at NHTSANHTSA communication ID: 10056607
NHTSA source summary · Original PDF not reviewed by Recallfolio
CHEVROLET/CADILLAC: WITH ENGINE UNAVAILABLE AND PROPULSION POWER REDUCED, CHECK ENGINE LIGHT IS ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1B03, P0C01, P0C4E AND ROUGH OPERATION WITH ENGINE RUNNING. MODEL 2014-2015 ELR, 2011-2015 VOLT. *PE
Source components: ENGINE.
Source record 10056607 at NHTSANHTSA communication ID: 10050239
NHTSA source summary · Original PDF not reviewed by Recallfolio
BUICK/CHEVROLET/GMC/OPEL: POWER STEERING ASSISTANCE MALFUNCTIONS WHILE EITHER TURNING LEFT OR RIGHT. MODELS 2012 OPEL AMPERA, VOLT, 2013 LACROSSE, REGAL, EQUINOX, MALIBU, TERRAIN, OPEL INSIGNIA. *PE UPDATED 08/1/2013 *JS UPDATED 11/25/2013 *JS UPDATED 1/13/15. *PE
Source components: STEERING:ELECTRIC POWER ASSIST SYSTEM · STEERING:HYDRAULIC POWER ASSIST SYSTEM.
Source record 10050239 at NHTSANHTSA communication ID: 10043667
NHTSA source summary · Original PDF not reviewed by Recallfolio
CHEVROLET: GM TAC HAS PLACED, ON RESTRICTION, THE DRIVE MOTOR GENERATOR CONTROL MODULE PART, KNOWN AS PIM. *PE MODEL 2011-2014 VOLT, 2014 ELR. UPDATED 10/15/14. *PE UPDATED 02/25/15*LJ
Source components: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR.
Source record 10043667 at NHTSANHTSA communication ID: 10114271
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information of the JOB CARD, for a repair on vehicles and what is acceptable - customer authorization; Service manager approvals and transaction authorization; Details of concern, cause and correction; Labor Time; Technician ID and acoutablity of labor time; Proper documentation and retension of warranty parts; Accurate sublet charges and receipts; Add on concerns after the Job Card has been written.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10114271 at NHTSANHTSA communication ID: 10114270
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty bulletin provides labor operation numbers for customer concerns that can't be duplicated.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10114270 at NHTSANHTSA communication ID: 10114759
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availability.
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10114759 at NHTSANHTSA communication ID: 10114748
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D-37 history in the Vehicle Communication Interface Module or telematics communication interface control module. Engineering has determined that this code will only display in history on the scan tool and will not cause issues with OnStar system operation.
Source components: ELECTRICAL SYSTEM.
Source record 10114748 at NHTSANHTSA communication ID: 10114746
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that have a Malfunction Indicator Lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. Technician will need to perform published Service Information diagnostics. If technician finds carbon an upper engine and valve cleaning should be performed.
Source components: ENGINE.
Source record 10114746 at NHTSANHTSA communication ID: 10114267
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides information on top tier fuels and what brands are available.
Source components: FUEL SYSTEM, GASOLINE.
Source record 10114267 at NHTSANHTSA communication ID: 10081067
NHTSA source summary · Original PDF not reviewed by Recallfolio
14232 - SPECIAL COVERAGE. SOME VEHICLES MAY HAVE INCREASED FRICTION IN THE STEERING SYSTEM. THIS COULD CAUSE THE STEERING WHEEL TO STICK IN THE STRAIGHT-AHEAD POSITION AFTER DRIVING LONG DISTANCES ON A STRAIGHT HIGHWAY. THE STEERING WHEEL CAN BE TURNED BUT IT MAY REQUIRE INCREASED EFFORT. DEALERS ARE TO 1) REPLACE THE STEERING GEAR ON 2010-2012 MODEL YEAR VEHICLES; OR 2) REPROGRAM THE POWER STEERING CONTROL MODULE ON 2013-2014 MODEL YEAR VEHICLES.
Source components: STEERING.
Source record 10081067 at NHTSANHTSA communication ID: 10114262
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin explains a normal condition for what and how the drive line can clunk.
Source components: PARKING BRAKE:DRIVELINE.
Source record 10114262 at NHTSANHTSA communication ID: 10114260
NHTSA source summary · Original PDF not reviewed by Recallfolio
This information bulletin explains the use of drilling high strength steel in a collision repair and the GM recommended CryoCobalt Drill bit.
Source components: FORWARD COLLISION AVOIDANCE.
Source record 10114260 at NHTSANHTSA communication ID: 10114244
NHTSA source summary · Original PDF not reviewed by Recallfolio
This technical bulletin provides a procedure on how to turn the transport mode message of and reset the battery light flashing.
Source components: ELECTRICAL SYSTEM.
Source record 10114244 at NHTSANHTSA communication ID: 10114711
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication advises the technician that the T18 Battery Charger part number 22799689, 24265980 and 24270696 is being placed on restriction through the General Motors Technical Assistance Center. Dealer will need to call General Motors Technical Assistance Center for further assistance.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY · EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114711 at NHTSANHTSA communication ID: 10114243
NHTSA source summary · Original PDF not reviewed by Recallfolio
This preliminary bulletin provides a procedure to replace both outter mirriors in the customers concern is a wind buffeting noise when the windows operate.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114243 at NHTSANHTSA communication ID: 10114705
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the existing cellular provider not having roaming agreements in areas outside of Canada to support transmitting of the packet data required for Turn-By-Turn feature to operate. The customer has 3 options while traveling through the United Sates. First if the vehicle is equipped with a navigation radio they can request a "Destination Download" to the vehicle. Second if the customer uses the OnStar RemoteLink app they can send the directions to the vehicle. The third option would be to have the vehicle loaded with a ?500 phone number? The customer will no longer be able to use their Hands Free Calling minutes when the new 500 phone number is loaded. If a customer chooses to restore Hands Free Calling in the future a new phone number will be assigned to the vehicle; previous phone numbers are not available.
Source components: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM).
Source record 10114705 at NHTSANHTSA communication ID: 10114240
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10114240 at NHTSANHTSA communication ID: 10114239
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty bulletin clarifies the use of dealer empowerment to satisfy the customer.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10114239 at NHTSANHTSA communication ID: 10253579
NHTSA source summary · Original PDF not reviewed by Recallfolio
Wind Buffeting (Noise) when Power Windows Operated.
Source components: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS.
Source record 10253579 at NHTSANHTSA communication ID: 10253169
NHTSA source summary · Original PDF not reviewed by Recallfolio
DTC P0335 And Or P0336 Stored In The T6 Power Inverter Module.
Source components: POWER TRAIN.
Source record 10253169 at NHTSANHTSA communication ID: 10253159
NHTSA source summary · Original PDF not reviewed by Recallfolio
T18 Battery Charge Module.
Source components: ELECTRICAL SYSTEM.
Source record 10253159 at NHTSANHTSA communication ID: 10252163
NHTSA source summary · Original PDF not reviewed by Recallfolio
XM Audio Traffic And Travel Link Availability And Operation.
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10252163 at NHTSANHTSA communication ID: 10250082
NHTSA source summary · Original PDF not reviewed by Recallfolio
Information on Driveline Clunk Noise
Source components: POWER TRAIN.
Source record 10250082 at NHTSANHTSA communication ID: 10248748
NHTSA source summary · Original PDF not reviewed by Recallfolio
Special Coverage Adjustment ? Power Steering Stick-Slip
Source components: POWER TRAIN · STEERING.
Source record 10248748 at NHTSANHTSA communication ID: 10247063
NHTSA source summary · Original PDF not reviewed by Recallfolio
A/C Blows Warm Or Poor Performance.
Source components: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM.
Source record 10247063 at NHTSANHTSA communication ID: 10246569
NHTSA source summary · Original PDF not reviewed by Recallfolio
Information on Driveline Clunk Noise
Source components: POWER TRAIN:DRIVELINE.
Source record 10246569 at NHTSANHTSA communication ID: 10245951
NHTSA source summary · Original PDF not reviewed by Recallfolio
Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10245951 at NHTSANHTSA communication ID: 10245760
NHTSA source summary · Original PDF not reviewed by Recallfolio
Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Source components: EQUIPMENT:ELECTRICAL.
Source record 10245760 at NHTSANHTSA communication ID: 10069965
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: EQUIPMENT.
Source record 10069965 at NHTSANHTSA communication ID: 10069963
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10069963 at NHTSANHTSA communication ID: 10069292
NHTSA source summary · Original PDF not reviewed by Recallfolio
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Source components: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS.
Source record 10069292 at NHTSANHTSA communication ID: 10057600
NHTSA source summary · Original PDF not reviewed by Recallfolio
GENERAL MOTORS 2011-2015 CHEVROLET VOLT, 2012-2015 OPEL AMPERA, 2014 CADILLAC ELR: PRELIMINARY INFORMATION REGARDING (EREV) DTC P0336 STORED IN THE T6 POWER INVERTER MODULE(HPCM). *LJ
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10057600 at NHTSANHTSA communication ID: 10057599
NHTSA source summary · Original PDF not reviewed by Recallfolio
GENERAL MOTORS: 2011-2015 CHEVROLET VOLT, 2014-2015 CADILLAC: PI REGARDING ELR BATTERY CHARGE MODULE(OBCM) PART RESTRICTION. PLEASE DISCARD PI 4845D. *LJ
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10057599 at NHTSANHTSA communication ID: 10135367
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician with the steps to diagnose and repair vehicles with a Malfunction Indicator Lamp on. Technician may find a Diagnostic Trouble Code P0335 and or P0336 stored in the Power inverter module. Technician will need to inspect G113 if the ground eyelet is not tight replacing the bolt with a shorter bolt. If either of the Diagnostic Trouble Codes P0335 or P0336 are stored in both the Engine Control Module and the Power inverter module or the codes are current, please follow published Service Information diagnostics. If the vehicle is a model year 2014, update the Power Inverter Module with the latest software in TIS2Web.
Source components: ELECTRICAL SYSTEM.
Source record 10135367 at NHTSANHTSA communication ID: 10135356
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
Source components: EQUIPMENT:APPLIANCE:AIR CONDITIONER.
Source record 10135356 at NHTSANHTSA communication ID: 10114328
NHTSA source summary · Original PDF not reviewed by Recallfolio
This information for Warranty administration - Changes the Service Policy and Procedures Section 1.6.2.11 and now is refered to Article 3.2.9 of the 1st addition manual for details of Technician Identification and Accounting of Labor Time
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114328 at NHTSANHTSA communication ID: 10114309
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin explains how to care for wiper blades.
Source components: VISIBILITY:WINDSHIELD WIPER/WASHER.
Source record 10114309 at NHTSANHTSA communication ID: 10135344
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about the terminated leads for X51L Left Instrument Fuse block, X51R Right Instrument Fuse block, and X53 Rear Fuse block. Dealer can order the terminated leads through the Warranty Parts Center.
Source components: ELECTRICAL SYSTEM.
Source record 10135344 at NHTSANHTSA communication ID: 10135343
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication advises the technician that the Drive Motor Generator Control Module part number 24266807 is being placed on restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
Source components: ELECTRICAL SYSTEM.
Source record 10135343 at NHTSANHTSA communication ID: 10135342
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspect for a poor crimp on the grounds ring terminal at the engine block for the bank with the concern and repair the wire.
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR.
Source record 10135342 at NHTSANHTSA communication ID: 10135337
NHTSA source summary · Original PDF not reviewed by Recallfolio
This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the existing cellular provider not having roaming agreements in areas outside of Canada to support transmitting of the packet data required for Turn-By-Turn feature to operate. The customer has 3 options while traveling through the United Sates. First if the vehicle is equipped with a navigation radio they can request a "Destination Download" to the vehicle. Second if the customer uses the OnStar RemoteLink app they can send the directions to the vehicle. The third option would be to have the vehicle loaded with a ?500 phone number? The customer will no longer be able to use their Hands Free Calling minutes when the new 500 phone number is loaded. If a customer chooses to restore Hands Free Calling in the future a new phone number will be assigned to the vehicle; previous phone numbers are not available.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10135337 at NHTSANHTSA communication ID: 10114299
NHTSA source summary · Original PDF not reviewed by Recallfolio
This informational bulletin provides a quick guide to updating which model vehicle after replacing the IPC.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114299 at NHTSANHTSA communication ID: 10114296
NHTSA source summary · Original PDF not reviewed by Recallfolio
This warranty administration bulletin provide policy information of the JOB CARD, for a repair on vehicles and what is acceptable - customer authorization; Service manager approvals and transaction authorization; Details of concern, cause and correction; Labor Time; Technician ID and acoutablity of labor time; Proper documentation and retension of warranty parts; Accurate sublet charges and receipts; Add on concerns after the Job Card has been written.
Source components: EQUIPMENT ADAPTIVE/MOBILITY.
Source record 10114296 at NHTSA