Original record summaries, dates and identifiers for this model-year. Records 201–260 of 260, ordered newest first. Dated records on this page: Feb 11, 2004–Jul 23, 2010.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Jul 23, 2010Service Bulletin/Repair Instructions
TT 87-10-05
NHTSA communication ID: 10124477
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms. If the reading is high or low when checked at the fan module, be sure to double check right at the coil to rule out any wiring concerns. Additionally, check ground circuit integrity for the clutch coil.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. 2001-2007 PASSA/PASSAT WAGON. *PE UPDATED 8/9/10. *PE UPDATED 11/8/10. *PE UPDATED 12/8/10. *PE UPDATED 2/28/11. *PE UPDATED 3/21/11. *PE
Source components: ELECTRICAL SYSTEM:IGNITION · ENGINE AND ENGINE COOLING:ENGINE:GASOLINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE
Source components: ELECTRICAL SYSTEM:IGNITION · ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. NO MODELS LISTED. *PE
Source components: ELECTRICAL SYSTEM:IGNITION · ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: DRIVETRAIN BINDING/TIRES SCRUBBING DURING LOW SPEED MANEUVERING, ESP LIGHT IN INSTRUMENT CLUSTER ON OR FLASHING. TENSION IN DRIVETRAIN; VIBRATION AND LOAD SENSITIVE KNOCKING FROM THE DRIVETRAIN; CRACKING NOISE UPON ACCELERATION FROM STOP, WHILE CORNERING OR DRIVING SLOWLY; SHUDDER WHEN CORNERING; RUBBING OR SLIPPING WHEN CORNERING; ELECTRONIC FAULTS IN 22 FOUR WHEEL DRIVE ELECTRONICS-DTC'S 02033, 02039, 02042 OR 02400 STORED. *PE
Source components: PARKING BRAKE:DRIVELINE · POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: THE WIRING HARNESS LOCATED ON THE DRIVER'S SIDE FLOOR PAN NEAR THE A PILLAR MAY HAVE A CORRODED SPLICE(S) CONNECTION. LOCATE SPLICE TO DETERMINE POSSIBLE CORROSION. REPAIR WIRING AS PER REPAIR MANUAL. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM · STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN: A/C INOPERATIVE, EVAPORATOR TEMPERATURE SENSOR-G308-DAMAGED OR DISLODGED. SYMPTOMS CAN BE POOR HEAT, NO COOLING, OR INSUFFICIENT COOLING. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2004-2005 MY TOUAREG - INSPECT DRIVER'S AND PASSENGER'S SIDE IMPACT AIRBAG CONNECTORS AND INSTALL WIRING HARNESS KIT(S), IF NECESSARY. CSC WAS RECEIVED. *NJ
NHTSA source summary · Original PDF not reviewed by Recallfolio
MALFUNCTION INDICATOR LAMP (MIL) IS ON, DIAGNOSTIC TROUBLE CODES (DTCS) P1411, P1423, SECONDARY AIR INJECTION SYSTEM BANK 1, BANK 2, FLOW TOO LOW ARE STORED IN DTC MEMORY. *TT
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
BATTERY CUT-OFF SWITCH, DISCONNECTING AND REMOVING DURING THE PRE-DELIVERY INSPECTION (PDI). THIS BULLETIN SUPERSEDES GROUP 00 NUMBER 04-02 DATED APR 6, 2004 AND GROUP 00 NUMBER 04-03 DATED APR 28, 2004. *TT
NHTSA source summary · Original PDF not reviewed by Recallfolio
A RUBBER PART CAN RUB AGAINST THE POWER STEERING AND/OR TRANSMISSION FLUID LINES LOCATED BEHIND THE RADIATOR GRILLE. THIS RUBBING CAN LEAD TO CORROSION OF THE LINES AND POSSIBLY EVEN A FLUID LEAK. *TT
Source components: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES · STEERING:HYDRAULIC POWER ASSIST SYSTEM.
NHTSA source summary · Original PDF not reviewed by Recallfolio
AIRBAG LIGHT IN INSTRUMENT CLUSTER IS ON AND ONE OR BOTH OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES ARE STORED IN DIAGNOSTIC TROUBLE CODES (DTC) MEMORY. *MJ
Source components: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY. INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ
NHTSA source summary · Original PDF not reviewed by Recallfolio
INSTRUMENT CLUSTER MULTI-FUNCTION DISPLAY SHOWS AN AIR SUSPENSION ERROR MESSAGE. DIAGNOSTIC TROUBLE CODES (DTCS) 00774, 00775, 00776, 01769 MAY ALSO BE STORED IN MEMORY. *TT