2019 Toyota RAV4 Manufacturer communications & TSBs.Page 2
Original record summaries, dates and identifiers for this model-year. Records 101–200 of 303, ordered newest first. Dated records on this page: Jul 29, 2020–Jun 24, 2022.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Jun 24, 2022Service Bulletin/Repair Instructions
TSB002222Rev1
NHTSA communication ID: 10224117
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the vehicle?s AWD Dynamic Torque Vectoring Disconnect system from either the transfer assembly or rear differential carrier assembly when accelerating from a stop and/or on deceleration after driving the vehicle for 15 minutes or more. This condition occurs with ?Normal? drive mode selected during disconnect/connect timing of the AWD system
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the vehicle?s AWD Dynamic Torque Vectoring Disconnect system from either the transfer assembly or rear differential carrier assembly when accelerating from a stop and/or on deceleration after driving the vehicle for 15 minutes or more. This condition occurs with ?Normal? drive mode selected during disconnect/connect timing of the AWD system
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address this condition
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address this condition
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: This bulletin includes basic procedures for performing a rescue charge at battery on high voltage (HV) Ni-MH and Li-ion batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing the battery rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by audio suppliers, FTS, and/or FPEs
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Toyota vehicles equipped with an FKS engine
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation. This service bulletin provides a guide on how to prepare the interior of the vehicle prior to an odor remediation being performed, as well as contact information for an approved vendor who will arrange the remediation, and instructions on how to prepare the interior of the vehicle for reassembly once the remediation has been completed. Refer to all model and model year specific Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This service bulletin is to provide a general overview and direction for the odor remediation process
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: This Tech Tip ONLY applies to 2019 model year RAV4 Adventure/Limited grade vehicles equipped with torque vectoring AWD system. Some customers may experience a clicking type noise at approximately 20-30 mph with ?Normal? or ?ECO? drive mode selected..
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: To improve customer support of telematics connected services features, additional resources have been provided in the Service Lane - Knowledge Center.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions
Source components: BACK OVER PREVENTION · SERVICE BRAKES, HYDRAULIC.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?), which may be more pronounced after a cold soak. The steering angle value displayed in Techstream may be greater than +3° off when the steering wheel is held straight. Every time the vehicle?s battery is disconnected or discharged, the Steering Angle Neutral Point Memorization and the Steering Sensor Zero Point Calibration must be performed. These steps are consistent with Step 3 and 4 of the ?BEFORE INSPECTION? section of the Pre-Delivery Service Check Sheet
Source components: BACK OVER PREVENTION · ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY · STEERING · STEERING:STEERING WHEEL /HANDLE BAR:YAW/ANGLE SENSOR · WHEELS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal noise from the vehicle?s AWD Dynamic Torque Vectoring Disconnect system from either the transfer assembly or rear differential carrier assembly when accelerating from a stop and/or on deceleration after driving the vehicle for 15 minutes or more. This condition occurs with ?Normal? drive mode selected during disconnect/connect timing of the AWD system.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: When customers have a concern about a discharged battery, no start, or general battery concern, the DCA-8000 is the only appropriate tool to use for diagnosis
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. This condition is caused by a cavity wax/debris/substance that may block door drain holes and restrict water from draining properly. Follow the Repair Procedure in this bulletin to address this condition
Source components: BACK OVER PREVENTION · VEHICLE SPEED CONTROL.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address this condition
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year Electronic Wiring Diagram (EWD) and/or Repair Manual.
NHTSA source summary · Original PDF not reviewed by Recallfolio
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Toyota.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center in Dealer Daily as well.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used with applicable vehicles to deliver the update; however, the process for generating license keys differs from previous generations. Before attempting to perform a map update, the head unit?s expiration date must be checked. If the expiration date is still valid, a license key may be generated without the use of an activation card number. Updating the maps without the use of an activation card number is considered an Embedded Navigation Update (refer to pg. 10) and performing this process does not extend the duration of telematic map services. If the head unit?s expiration date is expired, or is expiring within the next 90 days, it should be recommended to the customer to purchase an activation number. Utilizing an activation number will initiate a Dynamic Navigation Update (refer to pg. 4). This Dynamic Navigation Update will perform the Embedded Navigation Update and provide telematic map services for a period of two years from the day that the Dynamic Navigation Update is performed. Activation card numbers are provided in an activation card number pamphlet available through the normal parts ordering system. Follow the process in this bulletin to perform the update.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. ?An ?Oil Pressure Low? warning message on the Multi-information Display (MID). ?A MIL ON condition with Diagnostic Trouble Codes (DTCs) P05202A (Engine Oil Pressure Sensor/Switch "A" Signal Stuck in Range) and/or P052477 (Engine Oil Pressure too low [Severe]). Moisture from blow-by gases condenses and accumulates in the engine oil during short trips in extreme cold weather. When the moisture in the oil freezes, the oil pressure may drop, and the aforementioned warning indicators may display. Follow the procedures in this bulletin to address these conditions.
Source components: ELECTRICAL SYSTEM · ENGINE · EQUIPMENT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation. This service bulletin provides a guide on how to prepare the interior of the vehicle prior to an odor remediation being performed, as well as contact information for an approved vendor who will arrange the remediation, and instructions on how to prepare the interior of the vehicle for reassembly once the remediation has been completed. Refer to all model and model year specific Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This service bulletin is to provide a general overview and direction for the odor remediation process.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some customers may encounter Bluetooth® connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone, or if they have restored their phone data/settings recently.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2022 model year RAV4 and RAV4 Hybrid, and 2021 ? 2022 model year RAV4 Prime vehicles may exhibit a sloshing or splashing noise from inside one or more door panels when driving, opening and/or closing a door, and/or braking. This condition is caused by a cavity wax/debris/substance that may block door drain holes and restrict water from draining properly. Follow the Repair Procedure in this bulletin to address this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after driving the vehicle for 15 ? 20 minutes or more. This condition occurs with Normal drive mode selected during disconnect/connect timing of the AWD system. Follow the procedures in this bulletin to address this condition.
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY · POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE).
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla Hybrid, Prius (excluding Limited), and Prius Prime (excluding XLE, LTD) vehicles equipped with Safety Connect may exhibit one or more of the following conditions: ?SOS button lights are inoperative. ?Bluetooth® microphone and voice command are inoperative. ?Right front audio speakers are inoperative. ?Connected services are inoperative. ?Remote start is inoperative. A replacement telematics transceiver assembly is now available to address these conditions. Follow the Repair Procedure in this bulletin to address these conditions.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop environments.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: NOTE: This document only applies to certain audio packages for the following vehicles. 2019 C-HR (Audio Plus & Premium Only) 2020 Prius (Audio Only) 2020 Prius Prime (Audio Plus Only) Head unit telematics services become inoperative after DCM replacement and activation if the guest has an ACTIVE Verizon Wi-Fi Pre-Paid subscription. Head unit services include Wi-Fi, Destination Assist, Dynamic Navigation, and Dynamic Voice Recognition. Verizon is not able to transfer the Pre-Paid subscription to the new DCM automatically. As a result, the guest is unable to use their head unit telematics services. At this time if the DCM is replaced and activated before confirming the guests Wi-Fi subscription status, this may require Verizon?s IT to perform a manual fix on the customer?s account. To simplify the diagnosis and prevent the unnecessary replacement of parts, please refer to the procedure below. NOTE: This Tech Tip does not apply if the guest is currently under their Wi-Fi Trial.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX® Tip) is available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington.
Source components: ELECTRICAL SYSTEM · FUEL SYSTEM, GASOLINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota apps fail to download. ?Bluetooth® is unable to automatically connect after key cycle. ?Abnormal microphone operation. ?Sirius XM® antenna disconnection history Diagnostic Trouble Code (DTC) B15FE. ?No outgoing voice during phone calls when using Apple CarPlay®. ?Incoming calls incorrectly show on the multi-information display (MID) when using Apple CarPlay®. ?CAN networking DTC B1321. ?Volume inoperative after using Siri®. ?Unable to adjust the treble audio setting. ?Song information flickering. ?Unable to select Sirius XM® music genre by voice recognition. ?Noise when hanging up call on handset. ?Transferred contacts do not match the number of handset contacts. ?Sirius XM® sound slow to start. ?Abnormal Toyota apps and Scout Operation Some 2020 model year Prius and Prius Prime, 2019 model year RAV4 and RAV4 Hybrid, and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1195), Premium Audio (version 1195), or Navigation (version 1035) or earlier may exhibit one or more of the following conditions: ?Unable to play audio source after incoming call. ?Software enhancements. ?Intermittent rebooting. ?Unable to register Bluetooth® devices from Bluetooth® Audio Mode. ?Unable to pair Android? devices after Google? apps update. ?Unable to access camera diagnosis system. ?USB audio does not resume. ?Intermittent Bluetooth® disconnection. ?Abnormal voice recognition operation. ?Phone call history does not update. ?Bluetooth® loses connection after USB connection is made. ?Clock not displayed on the map screen. ?Intermittent phone ringing with no incoming phone call.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some 2014-2021 model year vehicles equipped with Dynamic Torque Control AWD system may experience a ?Noise? or ?Abnormal Operation? condition from the rear differential front coupling. In some cases, even an ?AWD System Message? with or without a DTC may be present with or without other conditions present.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: This Tech Tip applies to 2019 model year RAV4 Adventure/Limited grade equipped with torque vectoring AWD system ONLY. Some customers may experience an abnormal noise from rear differential after driving the vehicle for 15-20 minutes or more. This condition occurs with ?Normal? drive mode selected.
Source components: EQUIPMENT · POWER TRAIN · POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: This Tech Tip applies to 2019 model year RAV4 Adventure/Limited grade equipped with torque vectoring AWD system ONLY. Some customers may experience an abnormal noise from rear differential after driving the vehicle for 15-20 minutes or more. This condition occurs with ?Normal? drive mode selected.
Source components: EQUIPMENT · POWER TRAIN · POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 model year Avalon and Avalon Hybrid vehicles equipped with Entune? Audio Plus (version 1002) or Entune? Premium Audio (version 1002) or earlier may exhibit one or more of the following conditions: ?Incorrect GPS date and time. ?Abnormal Bluetooth® operation. ?Abnormal Wi-Fi operation. ?Microphone remains on the screen after voice recognition failure. ?Unable to see text with headlights on (text is the same color as the background). Some 2019 ? 2020 model year Toyota vehicles equipped with Entune? Audio (version 1007), Entune? Audio Plus (version 1011), or Entune? Premium Audio (version 1011) or earlier may exhibit one or more of the following conditions: ?Phone does not auto-connect on startup. ?Intermittent black screen. ?Apple CarPlay® home screen widget turns white when USB flash drive is disconnected. ?Abnormal phone book sorting. ?Unable to see DCM Status when in dark red or dark blue modes. ?XM no signal banner appears at all times. ??Check antenna,? ?ID Displaying,? or ?Seeking? always displays on XM mode. ?Unable to switch Bluetooth® devices. ?Apps button is inactive in the voice recognition hint screen when using Apple CarPlay®. ?Incorrect Spanish translations. ?Voice recognition is not canceled during a phone call. ?Low Easy Speak volume. ?Voice recognition ?Web Search? is inoperative. ?Entune? apps are inoperative and ?When it is safe and legal to do so, please ensure your Entune? App Suite application is running and logged in on your phone? pop-up appears. ?Download screen appears even though nothing is being downloaded. ?Intermittent partially white screen. ?Screen intermittently locked. ?Text goes off the edge of the screen. ?Screen is black for 10 seconds after shifting out of Reverse when using Apple CarPlay® A software update is now available to address these conditions. Follow the Software Update Procedure in this bulletin to update the softwa
Source components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used with applicable vehicles to deliver the update; however, the process for generating license keys differs from previous generations. Before attempting to perform a map update, the head unit?s expiration date must be checked. If the expiration date is still valid, a license key may be generated without the use of an activation card number. Updating the maps without the use of an activation card number is considered an Embedded Navigation Update (refer to pg. 10) and performing this process does not extend the duration of telematic map services. If the head unit?s expiration date is expired, or is expiring within the next 90 days, it should be recommended to the customer to purchase an activation number. Utilizing an activation number will initiate a Dynamic Navigation Update (refer to pg. 4). This Dynamic Navigation Update will perform the Embedded Navigation Update and provide telematic map services for a period of two years from the day that the Dynamic Navigation Update is performed. Activation card numbers are provided in an activation card number pamphlet available through the normal parts ordering system. Follow the process in this bulletin to perform the update.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by audio suppliers, FTS, and/or FPEs.
Source components: ELECTRICAL SYSTEM · EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM).
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?), which may be more pronounced after a cold soak. The steering angle value displayed in Techstream may be greater than +3° off when the steering wheel is held straight. Every time the vehicle?s battery is disconnected or discharged, the Steering Angle Neutral Point Memorization and the Steering Sensor Zero Point Calibration must be performed.
Source components: BACK OVER PREVENTION · STEERING.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2021 model year Toyota vehicles equipped with an FKS engine.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.
Source components: BACK OVER PREVENTION · SERVICE BRAKES.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
RE: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns.
Source components: AIR BAGS · FUEL SYSTEM, GASOLINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DE: Toyota has received customer reports of certain 2019-2021 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington.+
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2021 model year RAV4 Hybrid vehicles may experience one or both of the following conditions: ?The fuel gauge displays less than full when the fuel nozzle automatically clicks off. ?The total amount of fuel dispensed while refueling is less than expected when the fuel nozzle automatically clicks off. Additionally, the distance to empty mileage displayed on the Multi-Information Display (MID) may be less than expected. To address these concerns a new fuel tank and fuel sender gauge were developed. Based on production location and timing, some vehicles may already have the updated fuel tank and/or fuel sender gauge installed. In cases where these vehicles exhibit this condition only replace the necessary pre-countermeasure part. Refer to the Production Change Information section in this bulletin to identify which group the vehicle belongs to and follow the Repair Procedure in this bulletin to address these conditions.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns.
Source components: AIR BAGS · FUEL SYSTEM, GASOLINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.
Source components: BACK OVER PREVENTION · SERVICE BRAKES.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota apps fail to download. ?Bluetooth® is unable to automatically connect after key cycle. ?Abnormal microphone operation. ?Sirius XM® antenna disconnection history Diagnostic Trouble Code (DTC) B15FE. ?No outgoing voice during phone calls when using Apple CarPlay®. ?Incoming calls incorrectly show on the multi-information display (MID) when using Apple CarPlay®. ?CAN networking DTC B1321. ?Volume inoperative after using Siri®. ?Unable to adjust the treble audio setting. ?Song information flickering. ?Unable to select Sirius XM® music genre by voice recognition. ?Noise when hanging up call on handset. ?Transferred contacts do not match the number of handset contacts. ?Sirius XM® sound slow to start. ?Abnormal Toyota apps and Scout Operation.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used with applicable vehicles to deliver the update; however, the process for generating license keys differs from previous generations. Before attempting to perform a map update, the head unit?s expiration date must be checked. If the expiration date is still valid, a license key may be generated without the use of an activation card number. Updating the maps without the use of an activation card number is considered an Embedded Navigation Update (refer to pg. 10) and performing this process does not extend the duration of telematic map services. If the head unit?s expiration date is expired, or is expiring within the next 90 days, it should be recommended to the customer to purchase an activation number. Utilizing an activation number will initiate a Dynamic Navigation Update (refer to pg. 4). This Dynamic Navigation Update will perform the Embedded Navigation Update and provide telematic map services for a period of two years from the day that the Dynamic Navigation Update is performed. Activation card numbers are provided in an activation card number pamphlet available through the normal parts ordering system. Follow the process in this bulletin to perform the update.
Source components: BACK OVER PREVENTION:SOFTWARE · EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) · STRUCTURE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2021 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear-view mirror(s) while driving. Mirror vibration can be observed at highway speeds of approximately 50 ? 70 mph on typical concrete/asphalt road surfaces. Follow the Repair Procedure in this bulletin to improve this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns.
NHTSA source summary · Original PDF not reviewed by Recallfolio
RE: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. An abnormal buzz or groan noise from that case can occur with Normal drive mode selected during disconnect/connect timing of the AWD system. This condition typically occurs between 20 and 30 mph when accelerating from a stop, and/or between 20 and 13 mph on deceleration after driving the vehicle for 15 minutes or longer. Although the front transfer case electro-magnetic clutch is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to abnormal buzz/groan noise from the front transfer case. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.3
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY · POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE).
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. An abnormal buzz or groan noise from that case can occur with Normal drive mode selected during disconnect/connect timing of the AWD system. This condition typically occurs between 20 and 30 mph when accelerating from a stop, and/or between 20 and 13 mph on deceleration after driving the vehicle for 15 minutes or longer. Although the front transfer case electro-magnetic clutch is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to abnormal buzz/groan noise from the front transfer case. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.3
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY · POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE).
NHTSA source summary · Original PDF not reviewed by Recallfolio
DL: This Customer Support Program provides coverage for a condition involving the front transfer case electro-magnetic clutch in certain 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles. An abnormal buzz or groan noise from that case can occur with Normal drive mode selected during disconnect/connect timing of the AWD system. This condition typically occurs between 20 and 30 mph when accelerating from a stop, and/or between 20 and 13 mph on deceleration after driving the vehicle for 15 minutes or longer. Although the front transfer case electro-magnetic clutch is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to abnormal buzz/groan noise from the front transfer case. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.3
Source components: EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY · POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE).
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla Hybrid, Prius (excluding Limited), and Prius Prime (excluding XLE, LTD) vehicles equipped with Safety Connect may exhibit one or more of the following conditions: ?SOS button lights are inoperative ?Bluetooth® microphone and voice command are inoperative ?Right front audio speakers are inoperative ?Connected services are inoperative ?Remote start is inoperative A replacement telematics transceiver assembly is now available to address these conditions. Follow the Repair Procedure in this bulletin to address these conditions.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: This bulletin includes basic procedures for performing an at battery rescue charge on high voltage (HV) Ni-MH and Li-ion batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing the battery rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 Hybrid vehicles may experience one or both of the following conditions: ?The fuel gauge displays less than full when the fuel nozzle automatically clicks off. ?The total amount of fuel dispensed while refueling is less than expected when the fuel nozzle automatically clicks off. Additionally, the distance to empty mileage displayed on the Multi-Information Display (MID) may be less than expected. To address these concerns a new fuel tank and fuel sender gauge were developed. Based on production location and timing, some vehicles may already have the updated fuel tank and/or fuel sender gauge installed. In cases where these vehicles exhibit this condition only replace the necessary pre-countermeasure part. Refer to the Production Change Information section in this bulletin to identify which group the vehicle belongs to and follow the Repair Procedure in this bulletin to address these conditions.
NHTSA source summary · Original PDF not reviewed by Recallfolio
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected.
NHTSA source summary · Original PDF not reviewed by Recallfolio
DP: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington.
NHTSA source summary · Original PDF not reviewed by Recallfolio
RE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Some customer reports have also noted the ?Distance to Empty? shown on the multi-information display is less than expected. Based on our investigation, Toyota believes these conditions to be primarily related to a variation of fuel tank shape and the potential for the fuel sender gauge to become inclined. These conditions can cause the fuel level to be read incorrectly and may cause the low fuel light to illuminate with more fuel in the tank than usual. Although the fuel tank and fuel sender gauge unit are covered by Toyota?s New Vehicle Limited Warranty for normal Basic Warranty coverage period, 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to refueling performance concerns. Note: Fuel tanks are covered under the normal California Emissions Control Warranty period, 7 years or 70,000 miles (whichever comes first), for the following states: Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington.
Source components: AIR BAGS · FUEL SYSTEM, GASOLINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: NOTE: This document only applies to certain audio packages for the following vehicles. 2019 C-HR (Audio Plus & Premium Only) 2020 Prius (Audio Only) 2020 Prius Prime (Audio Plus Only) Head unit telematics services become inoperative after DCM replacement and activation if the guest has an ACTIVE Verizon Wi-Fi Pre-Paid subscription. Head unit services include Wi-Fi, Destination Assist, Dynamic Navigation, and Dynamic Voice Recognition. Verizon is not able to transfer the Pre-Paid subscription to the new DCM automatically. As a result, the guest is unable to use their head unit telematics services. At this time if the DCM is replaced and activated before confirming the guests Wi-Fi subscription status, this may require Verizon?s IT to perform a manual fix on the customer?s account.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some 2019-2020 model year RAV4 HV vehicles may experience DTC codes P0AA649 / P1C8049. - P0AA649-Hybrid/EV Battery Voltage System Isolation Internal Electronic Failure - P1C8049-Hybrid/EV Battery Voltage System Isolation (Rear Motor Area) Internal Electronic Failure Vehicles exhibiting this condition have been experiencing a short in MGR connector due to corrosion.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota apps fail to download. ?Bluetooth® is unable to automatically connect after key cycle. ?Abnormal microphone operation. ?Sirius XM® antenna disconnection history Diagnostic Trouble Code (DTC) B15FE. ?No outgoing voice during phone calls when using Apple CarPlay®. ?Incoming calls incorrectly show on the multi-information display (MID) when using Apple CarPlay®. ?CAN networking DTC B1321. ?Volume inoperative after using Siri®. ?Unable to adjust the treble audio setting. ?Song information flickering. ?Unable to select Sirius XM® music genre by voice recognition. ?Noise when hanging up call on handset. ?Transferred contacts do not match the number of handset contacts. ?Sirius XM® sound slow to start. ?Abnormal Toyota apps and Scout Operation. Some 2020 model year Prius and Prius Prime, 2019 model year RAV4 and RAV4 Hybrid, and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1195), Premium Audio (version 1195), or Navigation (version 1035) or earlier may exhibit one or more of the following conditions: ?Unable to play audio source after incoming call. ?Software enhancements. ?Intermittent rebooting. ?Unable to register Bluetooth® devices from Bluetooth® Audio Mode. ?Unable to pair Android? devices after Google? apps update. ?Unable to access camera diagnosis system. ?USB audio does not resume.?Intermittent Bluetooth® disconnection. ?Abnormal voice recognition operation. ?Phone call history does not update. ?Bluetooth® loses connection after USB connection is made. ?Navigation inoperative. ?Microphone disconnected pop-up message. ?Clock not displayed on the map screen. ?Intermittent phone ringing with no incoming phone call.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after driving the vehicle for 15 ? 20 minutes or more. This condition occurs with Normal drive mode selected during disconnect/connect timing of the AWD system. Follow the Repair Procedure in this bulletin to address this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Perform the procedures outlined in this bulletin to address this condition.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some customers may encounter Bluetooth® connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone, or if they have restored their phone data/settings recently.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB Some 2019 ? 2020 model year RAV4 vehicles may exhibit an AWD Warning Light ON condition with Diagnostic Trouble Code (DTC) C13F800 (4WD/AWD Rear Disconnect System Performance) present. Follow the Repair Procedure in this bulletin to address this condition.
Source components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Any HVAC repair requiring reassembly of the quick connect fitting between the suction hose sub-assembly and the suction pipe sub-assembly located at the top right of the engine compartment.
Source components: ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS · EQUIPMENT:APPLIANCE:AIR CONDITIONER.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Any HVAC repair requiring reassembly of the quick connect fitting between the suction hose sub-assembly and the suction pipe sub-assembly located at the top right of the engine compartment.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Steering Angle value displayed in Techstream may be greater than +3° off when the steering wheel is held straight. Every time the vehicle?s battery is disconnected or discharged, the Steering Angle Neutral Point memorization and the Steering Sensor Zero Point Calibration must be performed. These steps are consistent with Step 3 and 4 of the ?BEFORE INSPECTION? section of the Pre- Delivery Service Check Sheet
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced after a cold soak. Steering Angle value displayed in Techstream may be greater than +3° off when the steering wheel is held straight. Every time the vehicle?s battery is disconnected or discharged, the Steering Angle Neutral Point memorization and the Steering Sensor Zero Point Calibration must be performed. These steps are consistent with Step 3 and 4 of the ?BEFORE INSPECTION? section of the Pre- Delivery Service Check Sheet
Source components: ELECTRICAL SYSTEM · EQUIPMENT · STEERING.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Mirror vibration can be observed at highway speeds of approximately 50 ? 70 mph on typical concrete/asphalt road surfaces.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2019 ? 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Mirror vibration can be observed at highway speeds of approximately 50 ? 70 mph on typical concrete/asphalt road surfaces.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used with applicable vehicles to deliver the update; however, the process for generating license keys differs from previous generations. Before attempting to perform a map update, the head unit?s expiration date must be checked. If the expiration date is still valid, a license key may be generated without the use of an activation card number. Updating the maps without the use of an activation card number is considered an Embedded Navigation Update (refer to pg. 10) and performing this process does not extend the duration of telematic map services. If the head unit?s expiration date is expired, or is expiring within the next 90 days, it should be recommended to the customer to purchase an activation number. Utilizing an activation number will initiate a Dynamic Navigation Update (refer to pg. 4). This Dynamic Navigation Update will perform the Embedded Navigation Update and provide telematic map services for a period of two years from the day that the Dynamic Navigation Update is performed. Activation card numbers are provided in an activation card number pamphlet available through the normal parts ordering system.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used with applicable vehicles to deliver the update; however, the process for generating license keys differs from previous generations. Before attempting to perform a map update, the head unit?s expiration date must be checked. If the expiration date is still valid, a license key may be generated without the use of an activation card number. Updating the maps without the use of an activation card number is considered an Embedded Navigation Update (refer to pg. 10) and performing this process does not extend the duration of telematic map services. If the head unit?s expiration date is expired, or is expiring within the next 90 days, it should be recommended to the customer to purchase an activation number. Utilizing an activation number will initiate a Dynamic Navigation Update (refer to pg. 4). This Dynamic Navigation Update will perform the Embedded Navigation Update and provide telematic map services for a period of two years from the day that the Dynamic Navigation Update is performed. Activation card numbers are provided in an activation card number pamphlet available through the normal parts ordering system.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Specifically, we are looking at vehicle surge/hesitation condition (inconsistent acceleration) and would like to recover detailed customer voice and vehicle data.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Specifically, we are looking at vehicle surge/hesitation condition (inconsistent acceleration) and would like to recover detailed customer voice and vehicle data.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehicle; and 2020 model year Corolla Hybrid Vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0A80/P1AC000 and/or P0A7F/P1A8000 stored due to dust or debris buildup in the HV battery cooling fan and/or HV cooling filter. Follow the procedure in this bulletin to address this condition.
Source components: ELECTRICAL SYSTEM · ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN · EQUIPMENT.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0065-19. ?Production Change Information section has been updated. Service Bulletin No. T-SB-0065-19 is obsolete and any printed versions should be discarded. Some 2019 model year RAV4 Adventure and Limited grade AWD vehicles may exhibit an abnormal buzz/groan noise from the front transfer case at 20 ? 30 mph when accelerating from a stop and/or at 20 ? 13 mph on deceleration after driving the vehicle for 15 ? 20 minutes or more. This condition occurs with Normal drive mode selected during disconnect/connect timing of the AWD system. Follow the Repair Procedure in this bulletin to address this condition. This Service Bulletin ONLY applies to 2019 model year RAV4 Adventure and Limited grade vehicles with torque vectoring AWD system.