2011 Toyota HIGHLANDER Manufacturer communications & TSBs.Page 4
Original record summaries, dates and identifiers for this model-year. Records 301–315 of 315, ordered newest first. Dated records on this page: Jan 18, 1991–Oct 22, 2012.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
Oct 22, 2012Service Bulletin/Repair Instructions
T-SB-0091-12 Rev
NHTSA communication ID: 10133998
NHTSA source summary · Original PDF not reviewed by Recallfolio
Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does no close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases where the Power Back Door does not close, a pop or clunk noise may also be heard when the back door latch reaches the striker during the power close function.
NHTSA source summary · Original PDF not reviewed by Recallfolio
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles (160 km) at speeds less than 55 mph (90 km/h) with little or no damage to the tire.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: CHARGING SYSTEM INOPERATIVE. SOME ENGINES MAY EXHIBIT INSUFFICIENT CHARGING PERFORMANCE FROM THE ALTERNATOR. AN UPDATED PULLEY ASSEMBLY IS AVAILABLE TO ADDRESS THIS CONDITION. *JS
Source components: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR · ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS.
NHTSA source summary · Original PDF not reviewed by Recallfolio
TOYOTA: FLOOR MAT INSTALLATION DURING PDS. VEHICLES EQUIPPED WITH DRIVER'S SIDE FLOOR MAT RETAINING CLIPS TO SECURE THE FLOOR MAT IN CORRECT POSITION. *PE