103288
NHTSA communication ID: 11014869
NHTSA source summary · Original PDF not reviewed by Recallfolio
CAMERA - REAR VIEW
Source components: LANE DEPARTURE: BLIND SPOT DETECTION.
Source record 11014869 at NHTSAThe manufacturer’s record · Page 2 of 6
2021 Ram 2500
Manufacturer communications & TSBs.Page 2
Original record summaries, dates and identifiers for this model-year. Records 101–200 of 556, ordered newest first. Dated records on this page: May 24, 2023–Feb 17, 2025.
Back to 2021 Ram 2500 problems & recallsRead the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
103214
NHTSA communication ID: 11014838
NHTSA source summary · Original PDF not reviewed by Recallfolio
CONVERTER - CATALYTIC
Source components: ENGINE · UNKNOWN OR OTHER.
Source record 11014838 at NHTSA102940
NHTSA communication ID: 11014837
NHTSA source summary · Original PDF not reviewed by Recallfolio
CONVERTER - CATALYTIC
Source components: ENGINE · UNKNOWN OR OTHER.
Source record 11014837 at NHTSA9100393 Rev 1
NHTSA communication ID: 11013489
NHTSA source summary · Original PDF not reviewed by Recallfolio
TRANSFER CASE BW 44-46 If fluid leak is present between the transfer case and the rear driveshaft on a 4WD vehicle the Output Shaft Seal should be considered in lieu of entire transfer case or driveshaft replacement. In the case of major damage to components, contact StarCenter and/or proceed with replacements as necessary.
Source components: POWER TRAIN.
Source record 11013489 at NHTSA9003980
NHTSA communication ID: 11013232
NHTSA source summary · Original PDF not reviewed by Recallfolio
SWITCH Headlamp Before replacing the Headlamp Switch for faulty dimmer operation. Please follow the next steps to corroborate if the Headlamp Switch is malfunctioning: 1.- Please disconnect and reconnect the headlamp Switch. And verify if the issue is corrected. 2.- Review the internal resistance of the switch: a.- For the Right Dimmer (IP) between Pins 6 & 3. The value should be around 5.74 KOhms, when in the lowest position to 311 ohms in the top position (Parade Detent). b.- For the left Dimmer (Ambient Light) between pins 8 & 3. The value should be around 14.52 KOhms, when in the lowest position to 182 ohms in the top position. If a problem is found in the resistor values. Please replace the Switch.
Source components: ELECTRICAL SYSTEM.
Source record 11013232 at NHTSAS1408000384 REV.H
NHTSA communication ID: 11013171
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 11013171 at NHTSA99668
NHTSA communication ID: 11013634
NHTSA source summary · Original PDF not reviewed by Recallfolio
WIRING - JUMPER
Source components: ELECTRICAL SYSTEM.
Source record 11013634 at NHTSAS1425000019 REV.A
NHTSA communication ID: 11013055
NHTSA source summary · Original PDF not reviewed by Recallfolio
Malfunction Indicator Lamp (MIL) Illuminated. Diesel Exhaust Fluid (DEF) System Diagnostic Trouble Codes (DTCs) due to Hydrocarbon Contamination.
Source components: UNKNOWN OR OTHER.
Source record 11013055 at NHTSAS1408000384 REV.G
NHTSA communication ID: 11012777
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM.
Source record 11012777 at NHTSAS2310000003
NHTSA communication ID: 11012378
NHTSA source summary · Original PDF not reviewed by Recallfolio
The customer may experience an airbag light on or seat belt chime when buckled.
Source components: SEATS.
Source record 11012378 at NHTSA102387
NHTSA communication ID: 11012318
NHTSA source summary · Original PDF not reviewed by Recallfolio
SEAL - OUTPUT SHAFT
Source components: POWER TRAIN.
Source record 11012318 at NHTSA102307
NHTSA communication ID: 11012351
NHTSA source summary · Original PDF not reviewed by Recallfolio
GEAR - REACTION SUN
Source components: POWER TRAIN.
Source record 11012351 at NHTSAS2208000045 REV.B
NHTSA communication ID: 11011774
NHTSA source summary · Original PDF not reviewed by Recallfolio
Backup Camera Poor Image Quality Inspection
Source components: BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING.
Source record 11011774 at NHTSA101683
NHTSA communication ID: 11011155
NHTSA source summary · Original PDF not reviewed by Recallfolio
CONVERTER - CATALYTIC
Source components: ENGINE.
Source record 11011155 at NHTSA101773
NHTSA communication ID: 11011146
NHTSA source summary · Original PDF not reviewed by Recallfolio
CONVERTER - CATALYTIC
Source components: ENGINE.
Source record 11011146 at NHTSA25-008-24
NHTSA communication ID: 11010636
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Flash: Diesel Exhaust Fluid (DEF) Dosing Control Unit (DCU) Update Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P21C4-00 - Reductant Line Heater Relay Control Circuit High. ● U11C1-00 - Reductant Control Module Received Implausible Data From ECM/PCM. These DTCs will occur after installation of service DCU 68458603AB. This bulletin involves reprogramming the DCU with the latest available software."
Source components: UNKNOWN OR OTHER.
Source record 11010636 at NHTSAS2422000001 REV.C
NHTSA communication ID: 11010511
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
Source components: ELECTRICAL SYSTEM · WHEELS.
Source record 11010511 at NHTSA101232
NHTSA communication ID: 11010205
NHTSA source summary · Original PDF not reviewed by Recallfolio
Plate - Planetary
Source components: POWER TRAIN.
Source record 11010205 at NHTSA101094
NHTSA communication ID: 11010147
NHTSA source summary · Original PDF not reviewed by Recallfolio
TRANSMISSION KIT - WITH TORQUE CONVERTER
Source components: POWER TRAIN.
Source record 11010147 at NHTSA101092
NHTSA communication ID: 11010145
NHTSA source summary · Original PDF not reviewed by Recallfolio
TRANSMISSION KIT - WITH TORQUE CONVERTER
Source components: POWER TRAIN.
Source record 11010145 at NHTSA101094
NHTSA communication ID: 11009613
NHTSA source summary · Original PDF not reviewed by Recallfolio
TRANSMISSION KIT - WITH TORQUE CONVERTER
Source components: POWER TRAIN.
Source record 11009613 at NHTSA101092
NHTSA communication ID: 11009608
NHTSA source summary · Original PDF not reviewed by Recallfolio
TRANSMISSION KIT - WITH TORQUE CONVERTER
Source components: POWER TRAIN.
Source record 11009608 at NHTSAS2422000003
NHTSA communication ID: 11008900
NHTSA source summary · Original PDF not reviewed by Recallfolio
Trailer Tire Pressure Monitor (TTPM) Programming Tips And Operation Information.
Source components: WHEELS.
Source record 11008900 at NHTSA100498
NHTSA communication ID: 11009597
NHTSA source summary · Original PDF not reviewed by Recallfolio
MODULE - ENGINE CONTROLLER
Source components: ENGINE.
Source record 11009597 at NHTSAS2423000043
NHTSA communication ID: 11008436
NHTSA source summary · Original PDF not reviewed by Recallfolio
Dome Lamp LED And Incandescent Bulb Servicing.
Source components: ELECTRICAL SYSTEM.
Source record 11008436 at NHTSA100774
NHTSA communication ID: 11009561
NHTSA source summary · Original PDF not reviewed by Recallfolio
SWITCH - HEADLAMP
Source components: ELECTRICAL SYSTEM.
Source record 11009561 at NHTSA97802
NHTSA communication ID: 11008707
NHTSA source summary · Original PDF not reviewed by Recallfolio
SWITCH - HEADLAMP
Source components: ELECTRICAL SYSTEM.
Source record 11008707 at NHTSA25-006-24
NHTSA communication ID: 11008746
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Diesel Exhaust Fluid (DEF) Fluid Freezing Warranty Extension XR1 Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. Customers may also experience one or more of the following: ● Repeated freeze/thaw cycles of the urea tank to cause solid DEF crystals to form and settle on the focus tube, blocking the level sensor signal. ● Rapid temperature swings from below freezing to above freezing causing an incomplete thaw of the DEF tank. When the vehicle is powered on, the diagnostic is enabled due to thawed DEF at the tank bottom surface, but the fluid in the center is still partially frozen. ● Not following the proper DEF fill procedure and overfilling the tank. This bulletin involves replacing the urea delivery module and possibly updating the Dosing Control Unit (DCU) software"
Source components: ENGINE · UNKNOWN OR OTHER.
Source record 11008746 at NHTSA25-007-24
NHTSA communication ID: 11008745
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Diesel Exhaust Fluid (DEF) Fluid Freezing Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. Customers may also experience one or more of the following: ● Repeated freeze/thaw cycles of the urea tank to cause solid DEF crystals to form and settle on the focus tube, blocking the level sensor signal. ● Rapid temperature swings from below freezing to above freezing causing an incomplete thaw of the DEF tank. When the vehicle is powered on, the diagnostic is enabled due to thawed DEF at the tank bottom surface, but the fluid in the center is still partially frozen. ● Not following the proper DEF fill procedure and overfilling the tank This bulletin involves replacing the urea delivery module and grade vent valve and updating the Dosing Control Unit (DCU) software This bulletin involves replacing the urea delivery module and possibly updating the Dosing Control Unit (DCU) software"
Source components: ENGINE · UNKNOWN OR OTHER.
Source record 11008745 at NHTSAS2208000153 REV.B
NHTSA communication ID: 11008071
NHTSA source summary · Original PDF not reviewed by Recallfolio
Tire Pressure Lamp Flashing, No Tire Pressures Displayed, “Tire Pressure Module (TPM) System Unavailable” Message Displayed on Cluster
Source components: ELECTRICAL SYSTEM · WHEELS.
Source record 11008071 at NHTSA100681
NHTSA communication ID: 11008149
NHTSA source summary · Original PDF not reviewed by Recallfolio
Warranty Bulletin D-24-16 (XR1) Urea Delivery Module – Select 2019 - 2022 RAM Trucks (DJ/D2/DD/DP)
Source components: ENGINE · POWER TRAIN · UNKNOWN OR OTHER.
Source record 11008149 at NHTSA14-008-24
NHTSA communication ID: 11008196
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Diesel Exhaust Fluid (DEF) Fluid Freezing Warranty Extension XR1 Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. Customers may also experience one or more of the following: ● Repeated freeze/thaw cycles of the urea tank to cause solid DEF crystals to form and settle on the focus tube, blocking the level sensor signal. ● Rapid temperature swings from below freezing to above freezing causing an incomplete thaw of the DEF tank. When the vehicle is powered on, the diagnostic is enabled due to thawed DEF at the tank bottom surface, but the fluid in the center is still partially frozen. ● Not following the proper DEF fill procedure and overfilling the tank. This bulletin involves replacing the urea delivery module and possibly updating the Dosing Control Unit (DCU) software."
Source components: UNKNOWN OR OTHER.
Source record 11008196 at NHTSA100599
NHTSA communication ID: 11007994
NHTSA source summary · Original PDF not reviewed by Recallfolio
FCA Caribbean Warranty Bulletin ID-24-16 Rev. Announces the addition of the Rear Axle Assembly replacement for 2019 - 2024 RAM 3500 Cab Chassis (DD), RAM 4500/ 5500 Cab Chassis (DP), RAM 3500 Pickup (D2), RAM 2500 Pickup (DJ), RAM 1500 Pickup (DS) and RAM 1500 Pickup (DT) vehicles to the Powertrain Pre-Authorization program to ensure proper repair of Rear Axle Assembly failures and to assist in quality improvements. REV.A
Source components: POWER TRAIN.
Source record 11007994 at NHTSA100595
NHTSA communication ID: 11007993
NHTSA source summary · Original PDF not reviewed by Recallfolio
WARRANTY BULLETIN D-24-15 announces the addition of the Rear Axle Assembly replacement for 2019 - 2024 RAM 3500 Cab Chassis (DD), RAM 4500/ 5500 Cab Chassis (DP), RAM 3500 Pickup (D2), RAM 2500 Pickup (DJ), RAM 1500 Pickup (DS) and RAM 1500 Pickup (DT) vehicles to the Powertrain Pre-Authorization program for all dealers (Base, Plus & Premium) to ensure proper repair of Rear Axle Assembly failures and to assist in quality improvements. REV.A
Source components: POWER TRAIN.
Source record 11007993 at NHTSAS228A000017 REV.A
NHTSA communication ID: 11007954
NHTSA source summary · Original PDF not reviewed by Recallfolio
Battery Drain Suspected or "Identified" From USB or Media Hub
Source components: ELECTRICAL SYSTEM.
Source record 11007954 at NHTSAS2423000027 REV.A
NHTSA communication ID: 11007172
NHTSA source summary · Original PDF not reviewed by Recallfolio
Horn Sound Is Weak, Off Tone, Or Inoperative.
Source components: ELECTRICAL SYSTEM.
Source record 11007172 at NHTSAS2423000039
NHTSA communication ID: 11006515
NHTSA source summary · Original PDF not reviewed by Recallfolio
Wiper Motor Inoperative. Wiper Doesn’t Work or Stops Randomly On Glass
Source components: ELECTRICAL SYSTEM.
Source record 11006515 at NHTSA31-001-24
NHTSA communication ID: 11005320
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels."
Source components: STRUCTURE:BODY.
Source record 11005320 at NHTSA9100393
NHTSA communication ID: 11005228
NHTSA source summary · Original PDF not reviewed by Recallfolio
TRANSFER CASE BW 44-46 If fluid leak is present between the transfer case and the rear driveshaft on a 4WD vehicle the Output Shaft Seal - service part numbers 68161329AA OR 68449218AA (max tow application) - should be considered in lieu of entire transfer case or driveshaft replacement. In the case of major damage to components, contact StarCenter and/or proceed with replacements as necessary
Source components: POWER TRAIN.
Source record 11005228 at NHTSA99399
NHTSA communication ID: 11005361
NHTSA source summary · Original PDF not reviewed by Recallfolio
MODULE - ANTI-LOCK BRAKE SYSTEM
Source components: SERVICE BRAKES.
Source record 11005361 at NHTSA99400
NHTSA communication ID: 11005359
NHTSA source summary · Original PDF not reviewed by Recallfolio
MODULE - ANTI-LOCK BRAKE SYSTEM
Source components: SERVICE BRAKES.
Source record 11005359 at NHTSAS2408000015 REV.C
NHTSA communication ID: 11004151
NHTSA source summary · Original PDF not reviewed by Recallfolio
Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed, Adding Remote Start
Source components: ELECTRICAL SYSTEM.
Source record 11004151 at NHTSA99150
NHTSA communication ID: 11005365
NHTSA source summary · Original PDF not reviewed by Recallfolio
MODULE KIT - UREA PUMP/LEVEL UNIT
Source components: ENGINE · UNKNOWN OR OTHER.
Source record 11005365 at NHTSA03-006-24
NHTSA communication ID: 11002804
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Rear Axle Vibration Shudder Or Chatter Customers may experience the following: ● A chatter, shudder, or vibration from the rear axle during turns. NOTE: This may happen more as the vehicle ages, especially if the vehicle is used extensively for towing or hauling heavy loads. The cause of the concern may be due to degradation of the rear axle fluid. It is very important to follow the routine maintenance schedules on these vehicles when it comes to changing the rear axle fluid if the vehicle is used primarily for towing or hauling heavy loads. If you experience a vehicle with the above condition, please perform the proper maintenance procedures for the rear axle and replace the fluid first before replacing any hardware components. NOTE: This service bulletin is only applicable to vehicles that have no history of an axle fluid replacement. If the vehicle usage includes police, taxi, fleet, off-road or frequent trailer towing, regular axle fluid changes are required every 3 years or 30,000 miles (whichever comes first) per the Maintenance Schedule in the vehicle Owner's Manual. This bulletin involves changing the rear axle lube to possibly address a chatter, shudder or vibration."
Source components: POWER TRAIN.
Source record 11002804 at NHTSA14-005-24
NHTSA communication ID: 11002802
NHTSA source summary · Original PDF not reviewed by Recallfolio
"Diesel Exhaust Fluid (DEF) Fluid Freezing **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC):** ● P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. Customers may also experience one or more of the following: ● Repeated freeze/thaw cycles of the urea tank to cause solid DEF crystals to form and settle on the focus tube, blocking the level sensor signal. ● Rapid temperature swings from below freezing to above freezing causing an incomplete thaw of the DEF tank. When the vehicle is powered on, the diagnostic is enabled due to thawed DEF at the tank bottom surface, but the fluid in the center is still partially frozen. ● Not following the proper DEF fill procedure and overfilling the tank.** This bulletin involves replacing the urea delivery module and grade vent valve and updating the Dosing Control Unit (DCU) software."
Source components: UNKNOWN OR OTHER.
Source record 11002802 at NHTSA90A Combo Rev1
NHTSA communication ID: 11003046
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification 90A Diesel Exhaust Fluid
Source components: UNKNOWN OR OTHER.
Source record 11003046 at NHTSA96076
NHTSA communication ID: 11002753
NHTSA source summary · Original PDF not reviewed by Recallfolio
MOTOR - WINDSHIELD WIPER & WIPERUNIT - WINDSHIELD WIPER
Source components: VISIBILITY/WIPER.
Source record 11002753 at NHTSA98927
NHTSA communication ID: 11002316
NHTSA source summary · Original PDF not reviewed by Recallfolio
MOTOR - WINDSHIELD WIPER & WIPERUNIT - WINDSHIELD WIPER
Source components: VISIBILITY/WIPER.
Source record 11002316 at NHTSA94006
NHTSA communication ID: 11002424
NHTSA source summary · Original PDF not reviewed by Recallfolio
WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER
Source components: VISIBILITY/WIPER.
Source record 11002424 at NHTSA94006
NHTSA communication ID: 11002315
NHTSA source summary · Original PDF not reviewed by Recallfolio
WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER
Source components: STRUCTURE:BODY.
Source record 11002315 at NHTSA98861
NHTSA communication ID: 11002314
NHTSA source summary · Original PDF not reviewed by Recallfolio
WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER.
Source components: STRUCTURE:BODY.
Source record 11002314 at NHTSA98323
NHTSA communication ID: 11000611
NHTSA source summary · Original PDF not reviewed by Recallfolio
MODULE - TELEMATICS
Source components: ELECTRICAL SYSTEM.
Source record 11000611 at NHTSA98354
NHTSA communication ID: 11000608
NHTSA source summary · Original PDF not reviewed by Recallfolio
Valve - EGR
Source components: ENGINE.
Source record 11000608 at NHTSAS1625000004 REV.A
NHTSA communication ID: 11001020
NHTSA source summary · Original PDF not reviewed by Recallfolio
On Board Diagnosis (OBD) Monitor Readiness Information
Source components: ENGINE · UNKNOWN OR OTHER.
Source record 11001020 at NHTSA98171
NHTSA communication ID: 11000600
NHTSA source summary · Original PDF not reviewed by Recallfolio
MODULE - ENGINE CONTROLLER
Source components: ELECTRICAL SYSTEM · ENGINE.
Source record 11000600 at NHTSA9100338REV1
NHTSA communication ID: 11000824
NHTSA source summary · Original PDF not reviewed by Recallfolio
"GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c. Check Alternator B+ Stud connection to be sure nut is securing positive cable terminal properly (i.e. nut is clamping terminal & connection is tight). d. Check fuse between the alternator B+ stud & PDC terminal to make sure it is not blown. e. Be sure to follow service manual sections on ALTERNATOR CONTROL CIRCUIT DIAGNOSTIC & ALTERNATOR SENSE CIRCUIT DIAGNOSTIC looking for any opens & shorts (to ground or battery voltage). 2. Check/verify all grounds in the charging system circuit a. Check tightness of mounting bolts securing alternator to engine block. Alternator is a case ground component. b. Check main ground from engine to chassis; connection must be tight. c. Check battery ground cable connections are tight. d. Potentially, loosen alternator mounting bolts, without removing alternator, and re-tighten to torque specifications in service manual. e. After all steps above are complete, re-start engine & check charging system operation. 3. Verify that the Smart Charging System is not the reason for alternator low voltage & current output (Amps). a. Alternator charging can be suspended during engine idle operation because of the Smart Charge strategy. b. Refer to service manual section ""System Operation - Smart Charging System"". c. Refer to Star Case S2008000031 Rev A for low charging voltage & Smart Charge Mode Voltage Range diagram & mode descriptions. d. The alternator has no internal regulator; thus, has no smart circuitry. All alternator control signals come from ECM. 4. If alternator is faulty, remove alternator & mounting bolts. Return alternator with bolts for analysis at QEC."
Source components: ENGINE.
Source record 11000824 at NHTSAS1908000050 REV.A
NHTSA communication ID: 11000992
NHTSA source summary · Original PDF not reviewed by Recallfolio
Checking Radio Software Level On A VP2 Radio
Source components: ELECTRICAL SYSTEM.
Source record 11000992 at NHTSA98105
NHTSA communication ID: 11000174
NHTSA source summary · Original PDF not reviewed by Recallfolio
DAMPER - STRUT
Source components: STRUCTURE:BODY.
Source record 11000174 at NHTSAS2408000015 REV.B
NHTSA communication ID: 11000866
NHTSA source summary · Original PDF not reviewed by Recallfolio
Remote Keyless Entry (RKE) Button Functions Does Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed
Source components: ELECTRICAL SYSTEM.
Source record 11000866 at NHTSA0802924
NHTSA communication ID: 10251876
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Update from LR34.51 to LR35.41 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from LR34.51 to LR35.41. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10251876 at NHTSA0802824
NHTSA communication ID: 10251875
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Update from QR39.82F to QR40.12 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.82F to QR40.12. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10251875 at NHTSA0802624
NHTSA communication ID: 10251870
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Update from QR39.5 to QR40.11 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.5 to QR40.11. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10251870 at NHTSA0802524
NHTSA communication ID: 10251867
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.2 to QR40.11. NOTE: National launch for this FOTA update is expected to begin February 19, 2023.
Source components: ELECTRICAL SYSTEM:SOFTWARE.
Source record 10251867 at NHTSA0800624A
NHTSA communication ID: 10251848
NHTSA source summary · Original PDF not reviewed by Recallfolio
Navigation (NAV) Reboot When MOTA Fails The customer may describe one of more of the following: ? Radio navigation continues to reboot after a Map Update (MOTA). ? Navigation regularly cuts out and back on again. ? Radio switches to navigation without customer's input. This bulletin involves updating the Navigation maps via USB.
Source components: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM).
Source record 10251848 at NHTSAS1408000384
NHTSA communication ID: 10251783
NHTSA source summary · Original PDF not reviewed by Recallfolio
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
Source components: ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Source record 10251783 at NHTSA0825223
NHTSA communication ID: 10248948
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Update to LR34.31 to LR35.41 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from LR34.31 to LR35.41. NOTE: The National launch for this FOTA update campaign is expected to begin December 04, 2023.
Source components: ELECTRICAL SYSTEM:SOFTWARE · UNKNOWN OR OTHER.
Source record 10248948 at NHTSA0824523
NHTSA communication ID: 10248941
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from Q339.3 to QR39.62. NOTE: The National launch for this FOTA update campaign is expected to begin December 04, 2023.
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. · UNKNOWN OR OTHER.
Source record 10248941 at NHTSA0823023
NHTSA communication ID: 10247479
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Updating From QR39.6 to QR40.12 Software Version Customers may experience one or more of the following symptoms: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.6 to QR40.12. NOTE: National launch for this FOTA update is expected to begin November 06, 2023.
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. · UNKNOWN OR OTHER.
Source record 10247479 at NHTSA9100229
NHTSA communication ID: 10244356
NHTSA source summary · Original PDF not reviewed by Recallfolio
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
Source components: SUSPENSION.
Source record 10244356 at NHTSA9100226
NHTSA communication ID: 10248509
NHTSA source summary · Original PDF not reviewed by Recallfolio
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
Source components: ELECTRICAL SYSTEM.
Source record 10248509 at NHTSA9100226
NHTSA communication ID: 10244348
NHTSA source summary · Original PDF not reviewed by Recallfolio
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
Source components: ELECTRICAL SYSTEM:WIRING.
Source record 10244348 at NHTSARecall06A
NHTSA communication ID: 10248594
NHTSA source summary · Original PDF not reviewed by Recallfolio
Emissions Recall 06A - Vehicle Emission Control Information Label
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL.
Source record 10248594 at NHTSARecall06A
NHTSA communication ID: 10244433
NHTSA source summary · Original PDF not reviewed by Recallfolio
Emissions Recall 06A - Vehicle Emission Control Information Label
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL · EQUIPMENT:OTHER:LABELS.
Source record 10244433 at NHTSAS2208000011
NHTSA communication ID: 10248556
NHTSA source summary · Original PDF not reviewed by Recallfolio
Wireless Qi Charger Not Charging
Source components: ELECTRICAL SYSTEM.
Source record 10248556 at NHTSAS2208000011
NHTSA communication ID: 10244395
NHTSA source summary · Original PDF not reviewed by Recallfolio
Wireless Qi Charger Not Charging
Source components: EQUIPMENT:ELECTRICAL.
Source record 10244395 at NHTSA93341
NHTSA communication ID: 10248587
NHTSA source summary · Original PDF not reviewed by Recallfolio
FCA Caribbean Warranty Bulletin ID-22-22 - (X97) Diesel Particulate Filter (DPF) Select 2021 - 2022 Ram 2500 Pickup (DJ), 2021 - 2022 Ram 3500 Cab Chassis (DD), 2021 - 2022 Ram 3500 Pickup (D2) and 2021 - 2022 Ram 4500/5500 Cab Chassis (DP) (Rev. A)
Source components: FUEL SYSTEM, GASOLINE.
Source record 10248587 at NHTSA93335
NHTSA communication ID: 10248586
NHTSA source summary · Original PDF not reviewed by Recallfolio
Warranty Bulletin D-22-16 - (X97) Diesel Particulate Filter (DPF) Select 2021 - 2022 Ram 2500 Pickup (DJ), 2021 - 2022 Ram 3500 Cab Chassis (DD), 2021 - 2022 Ram 3500 Pickup (D2) and 2021 - 2022 Ram 4500/5500 Cab Chassis (DP) (Rev. A)
Source components: FUEL SYSTEM, DIESEL.
Source record 10248586 at NHTSA93341
NHTSA communication ID: 10244426
NHTSA source summary · Original PDF not reviewed by Recallfolio
FCA Caribbean Warranty Bulletin ID-22-22 - (X97) Diesel Particulate Filter (DPF) Select 2021 - 2022 Ram 2500 Pickup (DJ), 2021 - 2022 Ram 3500 Cab Chassis (DD), 2021 - 2022 Ram 3500 Pickup (D2) and 2021 - 2022 Ram 4500/5500 Cab Chassis (DP) (Rev. A)
Source components: FUEL SYSTEM, DIESEL.
Source record 10244426 at NHTSA93335
NHTSA communication ID: 10244425
NHTSA source summary · Original PDF not reviewed by Recallfolio
Warranty Bulletin D-22-16 - (X97) Diesel Particulate Filter (DPF) Select 2021 - 2022 Ram 2500 Pickup (DJ), 2021 - 2022 Ram 3500 Cab Chassis (DD), 2021 - 2022 Ram 3500 Pickup (D2) and 2021 - 2022 Ram 4500/5500 Cab Chassis (DP) (Rev. A)
Source components: FUEL SYSTEM, DIESEL.
Source record 10244425 at NHTSA93120
NHTSA communication ID: 10243209
NHTSA source summary · Original PDF not reviewed by Recallfolio
FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10243209 at NHTSA93023
NHTSA communication ID: 10243208
NHTSA source summary · Original PDF not reviewed by Recallfolio
Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10243208 at NHTSA2400623
NHTSA communication ID: 10243271
NHTSA source summary · Original PDF not reviewed by Recallfolio
A/C Diagnostic LOP Change
Source components: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM.
Source record 10243271 at NHTSA0901723
NHTSA communication ID: 10243261
NHTSA source summary · Original PDF not reviewed by Recallfolio
Diesel Particulate Filter (DPF) - X97 Warranty Extension Installation of Particulate Matter (PM) sensor.
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM · FUEL SYSTEM, DIESEL.
Source record 10243261 at NHTSAS1808000097
NHTSA communication ID: 10243157
NHTSA source summary · Original PDF not reviewed by Recallfolio
Back-Up Camera Inoperative Complaints, Radio Display Blue or Blank When Placed in Reverse
Source components: BACK OVER PREVENTION · BACK OVER PREVENTION:DISPLAY FUNCTION.
Source record 10243157 at NHTSAS2108000093
NHTSA communication ID: 10243153
NHTSA source summary · Original PDF not reviewed by Recallfolio
Apple CarPlay Does Not Work Or Not Connecting
Source components: COMMUNICATION:MANUFACTURER TELEMATICS · UNKNOWN OR OTHER.
Source record 10243153 at NHTSARecallY43
NHTSA communication ID: 10243212
NHTSA source summary · Original PDF not reviewed by Recallfolio
Emission Recall Y43 - Particulate Matter Sensor (Date on document incorrectly states "July 2023")
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL.
Source record 10243212 at NHTSAZD7
NHTSA communication ID: 10242779
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification ZD7 - Radio Software update
Source components: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10242779 at NHTSA9100196
NHTSA communication ID: 10242717
NHTSA source summary · Original PDF not reviewed by Recallfolio
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
Source components: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL.
Source record 10242717 at NHTSA0818123
NHTSA communication ID: 10242828
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Updating to QR40.12 Software Version ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.62 and QR39.57 to QR40.12. NOTE: National launch for this FOTA update is expected to begin August 16, 2023
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10242828 at NHTSAS2109000011
NHTSA communication ID: 10242765
NHTSA source summary · Original PDF not reviewed by Recallfolio
Squeak, Chirp, Or Tick Noise From The Serpentine Belt Area. Additional Diagnostics.
Source components: ENGINE AND ENGINE COOLING.
Source record 10242765 at NHTSA9004433
NHTSA communication ID: 10242706
NHTSA source summary · Original PDF not reviewed by Recallfolio
PUMP, Vacuum For DTC Code P258B - ELECTRONIC VACUUM PUMP PERFORMANCE. Due to brake vacuum pumps returned with trouble not found, please follow the proper diagnostics outline in the service library this also includes checking all electrical and vacuum hose connections prior to replacement of the vacuum pump. This will avoid unnecessary repair and potential charge back on the vacuum pump.
Source components: ELECTRICAL SYSTEM · SERVICE BRAKES · SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM.
Source record 10242706 at NHTSAS238A000034
NHTSA communication ID: 10242752
NHTSA source summary · Original PDF not reviewed by Recallfolio
USB Hub In-Operable
Source components: ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER.
Source record 10242752 at NHTSAS2208000011
NHTSA communication ID: 10242750
NHTSA source summary · Original PDF not reviewed by Recallfolio
Wireless Qi Charger Not Charging
Source components: EQUIPMENT:ELECTRICAL.
Source record 10242750 at NHTSA0901323
NHTSA communication ID: 10242795
NHTSA source summary · Original PDF not reviewed by Recallfolio
6.7L New Oil Usage Information Incorrect oil used. This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2023 to 2013 HD Trucks. The following information is intended to eliminate confusion.
Source components: ENGINE AND ENGINE COOLING.
Source record 10242795 at NHTSA2400623
NHTSA communication ID: 10241146
NHTSA source summary · Original PDF not reviewed by Recallfolio
A/C Diagnostic LOP Change (Except Alfa Romeo Vehicles)
Source components: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM.
Source record 10241146 at NHTSA0300323
NHTSA communication ID: 10241121
NHTSA source summary · Original PDF not reviewed by Recallfolio
Clicking Noise While In 4wd Ratcheting, Click, or Clicking noise in 4WD while turning. This bulletin involves replacing the front driveshaft.
Source components: ENGINE AND ENGINE COOLING · POWER TRAIN.
Source record 10241121 at NHTSAS2323000020
NHTSA communication ID: 10241026
NHTSA source summary · Original PDF not reviewed by Recallfolio
Power Side Steps Reverse, Stop In Motion, And/Or Do Not Deploy Or Stow
Source components: STRUCTURE:BODY:STEP/LADDER · UNKNOWN OR OTHER.
Source record 10241026 at NHTSAReferenceZD7
NHTSA communication ID: 10241056
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification ZD7 - Radio Software Update
Source components: ELECTRICAL SYSTEM · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10241056 at NHTSA0812923
NHTSA communication ID: 10239978
NHTSA source summary · Original PDF not reviewed by Recallfolio
Radio Over The Air Updating from PR39.92 to PR40.12 Software Version ? Radio Wi-Fi Hotspot connection not working. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from PR39.92 to PR40.12. NOTE: National launch for this FOTA update is expected to begin June 23, 2023.
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. · UNKNOWN OR OTHER.
Source record 10239978 at NHTSABulletinA
NHTSA communication ID: 10240002
NHTSA source summary · Original PDF not reviewed by Recallfolio
Customer Satisfaction Notification ZD7 - Radio Software Update
Source components: ELECTRICAL SYSTEM:SOFTWARE · EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC..
Source record 10240002 at NHTSA