2022 Hyundai
SANTA FEProblems & recalls

This bulletin provides information related to a Transmission Control Unit (TCU) software update for some vehicles equipped with an 8-speed wet dual clutch transmission (8WDCT). The software update revises the touch point learning variation, improving drivability and judder symptoms. Some 8WDCTs (indicated by a new part number) received an updated clutch spring. The correct TCU software update must be matched with the correct corresponding 8WDCT hardware, otherwise, drivability concerns may occur. This service procedure should be performed prior to any 8WDCT replacements done for drivability/judder concerns.

Components: POWER TRAIN. Confirm detailed applicability in the original document.

Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly.

Components: ELECTRICAL SYSTEM · ENGINE. Confirm detailed applicability in the original document.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

Components: AIR BAGS. Confirm detailed applicability in the original document.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

Components: AIR BAGS. Confirm detailed applicability in the original document.

Certain 2021 – 2023 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2022 – 2023 model year Santa Fe Plug-In Hybrid vehicles may experience an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. At Hyundai, we are committed to providing vehicles of outstanding quality and value. In an effort to meet this commitment, the warranty coverage for the horn assemblies under these conditions has been extended to 10 years/ 120,000 miles from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners.

Campaign / software reference: Z09

Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.

Some Santa Cruz (NXT), Santa Fe (TMA, MX5A), and Sonata (DN8A) models may require replacement of the 8-speed wet dual clutch transmission (8WDCT) when the vehicle sets one of the high pressure electric oil pump (HP EOP) DTCs listed below. This bulletin provides instructions to replace the 8WDCT.

Components: POWER TRAIN. Confirm detailed applicability in the original document.

Some Santa Fe (TMA) and Tucson (NX4A) vehicles equipped with a 2.5L GDI engine and 8 speed automatic transmission may have DTC U028700 (Lost Communication With Trans Fluid Pump Module) set by the transmission Electric Oil Pump (EOP). This DTC can cause the Idle Stop & Go (ISG) system to become inoperative. Follow the procedure in this bulletin to replace the Electric Oil Pump on affected vehicles.

Components: POWER TRAIN. Confirm detailed applicability in the original document.

Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. If a horn needs to be replaced, follow the instructions within this Technical Service Bulletin (TSB) 26-BE-001H-1 to install the latest design. Please note that any vehicles under 10 years/120,000 miles are covered by this TSB, even if vehicle is with original warranty of 5 years/60,000 miles.

Campaign / software reference: Z09

Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.

Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. If a horn needs to be replaced, follow the instructions within this TSB to install the latest design. Please note that any vehicles under 10 years/120,000 miles are covered by this TSB, even if vehicle is within original warranty of 5 years/60,000 miles.

Campaign / software reference: Z09

Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.

Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. If a horn needs to be replaced, follow the instructions within Technical Service Bulletin (TSB) to install the latest design. Please note that any vehicles under 10 years/120,000 miles are covered by this TSB, even if vehicle is within original warranty of 5 years/60,000 miles.

Campaign / software reference: Z09

Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.

Some Santa Fe (TMA) vehicles may have DTCs P218100, P2181F0, and/or P2181F1 (Cooling System Performance) set in the Electronic Control Unit (ECU), resulting in an illuminated Check Engine warning lamp. Follow the procedure in this TSB to replace the Integrated Thermal Management (ITM) module and update both the Engine Control Module (ECM) and Transmission Control Module (TCM) if applicable. Follow the flowchart in this TSB to update the appropriate modules.

Components: ENGINE. Confirm detailed applicability in the original document.

Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI fuel injectors leaking internally. This may be caused by internal filter breakage in the injector. Follow the procedure in this TSB to replace all 4 injectors on affected vehicles, using the kit in the Parts Information section.

Components: FUEL/PROPULSION SYSTEM. Confirm detailed applicability in the original document.