2008 Chevrolet AVEO Manufacturer communications & TSBs.Page 3
Original record summaries, dates and identifiers for this model-year. Records 201–222 of 222, ordered newest first. Dated records on this page: Dec 1, 2007–May 1, 2012.
Read the applicability before drawing a conclusion.
This archive includes service bulletins, warranty notices, software instructions and other communications. Records may repeat or supersede earlier instructions. A model-year association is not proof that a document covers every engine, trim, VIN or reported symptom, or that a repair is free.
NHTSA download snapshot: Sep 28, 2026. These are communication associations for this vehicle, not unique defects. How records are joined and counted.
May 1, 2012Service Bulletin/Repair Instructions
PIT5074F
NHTSA communication ID: 10044242
NHTSA source summary · Original PDF not reviewed by Recallfolio
GM: J-35616-64B TERMINAL TEST PROBE AND REPLACEMENT TERMINAL. ALSO INCLUDED MODELS VERANO, REGAL, LACROSSE, CTS, SRX, VOLT, SONIC, MALIBU, IMPALA, EQUINOX, CRUZE, AVALANCHE, TAHOE SUBURBAN, SILVERADO, SIERRA, YUKON, AND TERRAIN FOR MODEL YEAR 2013. MODEL ESCALADE MODEL YEAR 2012-2013. MODEL PONTIAC G3 MODEL YEAR 2007. MODEL WAVE MODEL YEARS 2005-2010. DENALI MODELS MODEL YEARS 2007-2013. *JS
NHTSA source summary · Original PDF not reviewed by Recallfolio
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/3/12. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
CHEVROLET: INTERMITTENT OR CONTINUOUS HIGH ENGINE RPM WHEN IDLING AT NORMAL OR WARMER OPERATING TEMPERATURES (INSTALL REPLACEMENT THROTTLE POSITION SENSOR (TPS) ELECTRICAL HARNESS CONNECTOR KIT). *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
GENERAL MOTORS: IT HAS BEEN IDENTIFIED THAT THE CURRENT FUEL GAUGE INACCURATE/INOPERATIVE DIAGNOSTICS IN SI-2000 ARE MISSING SOME VERY IMPORTANT INFORMATION. *PE UPDATED 2/16/11. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
CHEVROLET: HVAC BLOWER MOTOR INOPERATIVE; BLOWER MOTOR OPERATES ON HIGH SPEED ONLY (REPLACE BLOWER MOTOR AND RESISTOR). THIS CONDITION MAY BE CAUSED BY AN OPEN RESISTOR. *PE
NHTSA source summary · Original PDF not reviewed by Recallfolio
CHEVROLET: HVAC BLOWER MOTOR INOPERATIVE, BLOWER MOTOR OPERATES ON HIGH SPEED ONLY (REPLACE BLOWER MOTOR AND RESISTER). THIS CONDITION MAY BE CAUSED BY AN OPEN RESISTOR. THE BLOWER MOTOR OPERATES CORRECTLY AFTER REPLACING THE RESISTER, BUT THE RESISTOR MAY FAIL AGAIN DUE TO A FAULTY BLOWER MOTOR. *PE
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
CHEVROLET: INTERMITTENT ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON; WHEEL SPEED SENSOR (WSS)DTCS SET. GM ENGINEERING IS ATTEMPTING TO DETERMINE THE ROOT CAUSE OF THE CONDITION. *PE UPDATED 3/1/10. *PE
Source components: SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT · SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR · SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT · SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING.
NHTSA source summary · Original PDF not reviewed by Recallfolio
LXT, L91, POOR ACCELERATION, THROTTLE BODY FROZEN SHUT AND/OR STUCK CLOSED, MIL/SES LIGHT ILLUMINATED, DTC'S P1516, P2106 AND/OR P2110 SET IN EXTREMELY LOW TEMPERATURES WITH HIGH HUMIDITY CONDITION AFTER AN INITIAL COLD ENGINE START OR WHILE DRIVING, REDUCED ENGINE MODES (INSTALL PCV VALVE KIT AND REPROGRAM ECM) WITH 1.6L 4-CYLINDER ENGINE (VIN 6 - RPO'S LXT, L91). (CANADA ONLY 2006-08 MY PONTIAC WAVE) *NJ
Source components: ENGINE AND ENGINE COOLING:ENGINE.
NHTSA source summary · Original PDF not reviewed by Recallfolio
CRANKCASE CONTAMINATION DUE TO COOLANT IN THE ENGINE OIL - RESEAL CASTING PLUG. WITH BUILT BEFORE VIN BREAKPOINT 8B067818 (JULY 24, 2007) & 1.6L ENGINE (VIN 6 - RPO L91 OR LXT). *NJ
Source components: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV).