The vehicle dossier US · 2007
2007 Chevrolet
AVEOProblems & recalls
216 distinct owner reports in the NHTSA snapshot. Air bags appears in 84 of them. Explore what was reported—and which official actions are on file.
01 / Owner-reported evidence
What owners reported.
Categories attached to 216 distinct reports. A report can mention more than one component, so category totals can overlap.
See original component labels
These are reports made to NHTSA, not verified diagnoses. More reports can reflect more vehicles, more time on the road, or greater reporting activity.
The reporting timeline
When reports arrived.
Reports by year filed, not by the year a problem occurred. Showing the latest 15 years with reports.
52,000 miles is the median among 173 reports with usable mileage. The middle half spans 14,541–85,000 miles.
This describes the submitted reports. It does not predict when a vehicle will fail.
02 / Official safety campaigns
2 recall campaigns on file.
A campaign can cover only certain production dates or configurations. The count does not tell you whether an individual car has an open recall.
EXTERIOR LIGHTING:HEADLIGHTSCampaign 14V261000
Reported concern
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Manufacturer’s stated response
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Manufacturer campaign: 14093, 14236
Read campaign 14V261000 at NHTSAFUEL SYSTEM, GASOLINECampaign 06V398000
Reported concern
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.
Manufacturer’s stated response
DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Manufacturer campaign: 06133
Read campaign 06V398000 at NHTSA03 / The manufacturer’s record
Instructions. Updates. Responses.
210 distinct communications list this model-year. Showing the latest 12. A matching model-year does not establish that every engine, trim or reported symptom is covered.
PIC5650MThis Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagno…NHTSA ID 11021792
This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11021792 at NHTSAPIP5601CThis PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.NHTSA ID 11020816
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11020816 at NHTSAPIT5074RThis Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.NHTSA ID 11019074
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11019074 at NHTSAPIT5074RThis Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.NHTSA ID 11019073
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11019073 at NHTSAPIT5074RThis Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.NHTSA ID 11019072
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11019072 at NHTSA04-06-04-051JThis service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.NHTSA ID 11009531
This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
Components: ENGINE. Confirm detailed applicability in the original document.
Source record 11009531 at NHTSA08-07-30-026IThis service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight move…NHTSA ID 11009088
This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
Components: POWER TRAIN. Confirm detailed applicability in the original document.
Source record 11009088 at NHTSA02-00-89-002XThis service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).NHTSA ID 11008956
This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11008956 at NHTSAPIT3271PThis Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested an…NHTSA ID 11007208
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
Components: UNKNOWN OR OTHER. Confirm detailed applicability in the original document.
Source record 11007208 at NHTSAGeneral CommunicationVehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updatin…NHTSA ID 11006621
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
Campaign / software reference: General Communication
Components: ELECTRICAL SYSTEM. Confirm detailed applicability in the original document.
Source record 11006621 at NHTSA05-03-08-002JThis service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.NHTSA ID 11007936
This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
Components: SUSPENSION. Confirm detailed applicability in the original document.
Source record 11007936 at NHTSA05-03-08-002JThis service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.NHTSA ID 11007935
This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
Components: SUSPENSION. Confirm detailed applicability in the original document.
Source record 11007935 at NHTSARecords below contain the NHTSA bulk summary unless a document-reviewed explainer is linked. A service bulletin is not a safety recall or a promise of a free repair. Records may be revised or superseded; verify the current document with the manufacturer.
04 / Agency investigations
Official inquiries.
An investigation is an inquiry into a potential concern. Its presence does not establish a defect, and a closed case does not certify a car’s condition.
Your next step
Take good questions
to the inspection.
Use these prompts with a qualified inspector. This page is research, not a diagnosis or a substitute for a hands-on inspection.