2022 Hyundai
SONATAProblems & recalls

This bulletin provides information related to a Transmission Control Unit (TCU) software update for some vehicles equipped with an 8-speed wet dual clutch transmission (8WDCT). The software update revises the touch point learning variation, improving drivability and judder symptoms. Some 8WDCTs (indicated by a new part number) received an updated clutch spring. The correct TCU software update must be matched with the correct corresponding 8WDCT hardware, otherwise, drivability concerns may occur. This service procedure should be performed prior to any 8WDCT replacements done for drivability/judder concerns.

Components: POWER TRAIN. Confirm detailed applicability in the original document.

Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly.

Components: ELECTRICAL SYSTEM · ENGINE. Confirm detailed applicability in the original document.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

Components: AIR BAGS. Confirm detailed applicability in the original document.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

Components: AIR BAGS. Confirm detailed applicability in the original document.

Some Santa Cruz (NXT), Santa Fe (TMA, MX5A), and Sonata (DN8A) models may require replacement of the 8-speed wet dual clutch transmission (8WDCT) when the vehicle sets one of the high pressure electric oil pump (HP EOP) DTCs listed below. This bulletin provides instructions to replace the 8WDCT.

Components: POWER TRAIN. Confirm detailed applicability in the original document.

Some 2019MY and newer vehicles equipped with a front view camera may illuminate certain warning lights and trigger DTC C272246 fault code for the front camera. In the following cases, the front camera auto-calibration range may be exceeded while driving: • If the front camera is not properly installed and is completely or partially detached. • In case of excessive changes affecting the vehicle's balance (e.g., loading excessively heavy cargo in a specific location of the vehicle, or significant under-inflation of the tires). • Specific road conditions affecting the vehicle's balance (e.g., excessive road crown) This TSB provides instructions on how to service the vehicle when the front camera related warning light(s) are triggered due to system out of calibration (DTC_C272246).

Components: EXTERIOR LIGHTING · FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL · FORWARD COLLISION AVOIDANCE: WARNINGS · LANE DEPARTURE: ASSIST · LANE DEPARTURE: WARNING. Confirm detailed applicability in the original document.

Some Sonata (DN8, DN8A) vehicles may have DTCs P218100, P2181F0, and/or P2181F1 (Cooling System Performance) set in the Engine Control Module, resulting in an illuminated Check Engine warning lamp. Follow the procedure in this TSB to replace the Integrated Thermal Management (ITM) module and update both the Engine Control Module (ECM) and Transmission Control Module (TCM) if applicable. Follow the flowchart in this TSB to update the appropriate modules.

Components: ENGINE. Confirm detailed applicability in the original document.

Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI fuel injectors leaking internally. This may be caused by internal filter breakage in the injector. Follow the procedure in this TSB to replace all 4 injectors on affected vehicles, using the kit in the Parts Information section.

Components: FUEL/PROPULSION SYSTEM. Confirm detailed applicability in the original document.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

Components: EXTERIOR LIGHTING. Confirm detailed applicability in the original document.

This bulletin provides information related to the changes introduced in the 2025 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system as described in this TSB.

Components: ELECTRICAL SYSTEM. Confirm detailed applicability in the original document.

A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.

Campaign / software reference: TBW

Components: ELECTRICAL SYSTEM. Confirm detailed applicability in the original document.

Certain Santa Fe (TMA) and Sonata (DN8/DN8A) vehicles equipped with 8-speed dual clutch transmissions (8DCT) may exhibit one of the DTCs listed below, related to the high pressure electric oil pump (HP EOP). Follow the procedures in this TSB to update the Transmission Control Unit (TCU) to the latest sensorless logic on affected vehicles, and then perform air bleeding and transmission learning.

Components: POWER TRAIN. Confirm detailed applicability in the original document.