2016 Ford
F-150Problems & recalls

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Campaign reference in the source: 26V237

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Recorded closure: Jan 30, 2026

On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688

Recorded closure: Dec 17, 2018

Campaign reference in the source: 18V568000

On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751

Recorded closure: Jul 5, 2020

Campaign reference in the source: 20V332000