2007 BMW
530XIProblems & recalls

The basic conditions for initializing the power windows are not met.

Components: ELECTRICAL SYSTEM · VISIBILITY:POWER WINDOW DEVICES AND CONTROLS. Confirm detailed applicability in the original document.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Components: ELECTRICAL SYSTEM. Confirm detailed applicability in the original document.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Components: ENGINE AND ENGINE COOLING · FUEL SYSTEM, GASOLINE. Confirm detailed applicability in the original document.

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Components: ELECTRICAL SYSTEM · EQUIPMENT. Confirm detailed applicability in the original document.

Diagnosis of Compound Brake System Complaints in M Vehicles: 1. Visible cracks are caused by high thermal stresses during rapid heating and cooling of the brake discs. Braking from high speed with cold brake components (less than 212 degrees F) increases the likelihood of cracks to form.

Components: SERVICE BRAKES, AIR:DISC · STEERING: STEERING WHEEL/HANDLE BAR. Confirm detailed applicability in the original document.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

Components: ELECTRICAL SYSTEM · EQUIPMENT · EQUIPMENT ADAPTIVE/MOBILITY. Confirm detailed applicability in the original document.

Power Reduction, FC2A82 Intake VANOS and/or FC2A87 Exhaust VANOS Camshaft Fault: The ?Service Engine Soon? (MIL) lamp is illuminated and engine power reduction is perceived. This situation can occur after driving for some time with the engine at full operating temperature. If theignition is cycled, the engine then usually performs normally.

Components: ENGINE AND ENGINE COOLING. Confirm detailed applicability in the original document.

Power Reduction FC2A82 Intake VANOS and/or FC2 A87 Exhaust VANOS Camshaft Fault: The "Service Engine Soon" (MIL) lamp is illuminated and engine power reduction is perceived. This situation can occur after driving for some time with the engine at full operating temperature. If the ignition is cycled the engine then usually performs normally.

Components: ELECTRICAL SYSTEM · POWER TRAIN. Confirm detailed applicability in the original document.

Various Electrical Problems Caused by Water Ingress. Water ingress into the luggage compartment may cause various electrical problems or faults associated with the MPM (Micro Power Module); PDC (Park Distance Control); M-ASK (Multi-Audio System Controller); CCC (Car Communication Computer); CID (Control Information Display); TCU (Telematics Control Unit); LOGIC-7 (Top Hi-Fi); RDC (Tire Pressure Monitor) or SDARS (Satellite Radio Receiver) control modules. In most cases, the water collects in the spare wheel recess. CAUSE: Insufficient sealing may allow water to enter the luggage compartment due to the vacuum generated while driving.

Components: ELECTRICAL SYSTEM · STRUCTURE. Confirm detailed applicability in the original document.

Various Electrical Problems. There are various electrical malfunctions, for example: central locking, radio reception, tailgate, and rear lighting. Fatigued and broken wires in the tailgate harness. The problem may affect either the left or the right side harness at the tailgate.

Components: ELECTRICAL SYSTEM. Confirm detailed applicability in the original document.

"Power Reduction, FC 2A82 Intake VANOS and/or FC 2A87 Exhaust VANOS Camshaft Faults are Stored in DME. The ""Service Engine Soon"" (MIL) lamp is illuminated and engine power reduction is perceived. This situation can occur after driving for some time with the engine at full operating temperature. If the ignition is cycled, the engine then usually performs normally. The following faults are stored in the DME: * 2A82 VANOS intake - stiff; jammed mechanically * 2A87 VANOS exhaust - stiff; jammed mechanically * 130108 VANOS intake: control fault, position not reached * 130308 VANOS exhaust: control fault, position not reached For the N54 engine, the following secondary faults may also be stored: * 120408 Charge-air pressure control, cut-out: Boost pressure accumulation blocked * 3100 Boost-pressure control, deactivation - boost-pressure buildup prohibited CAUSE The VANOS faults can be caused by an insufficient oil pressure supply to the inlet VANOS adjustment unit. To effectively move the camshafts to the target positions in the specified time and under all engine conditions, sufficient oil pressure supply to the VANOS control pistons must always be available. If engine operation requires the VANOS system to quickly advance or retard the intake or exhaust camshaft, faults may be stored if the camshaft is ""late"", or does not reach the target position. In this situation, engine power may be reduced and a check control message is displayed. The consequential fault 3100 or 120408 can also be set in the DME fault memory as well."

Components: ENGINE · EQUIPMENT. Confirm detailed applicability in the original document.

"?CLASS ACTION LAW SUIT SETTLEMENT: WATER INTRUSION AND ACCUMULATION IN THE TRUNK (E60)/REAR CABIN WELL AREA (E61). INFORMATION BMW of North America, LLC (?BMW NA?) is has entered into a court approved ?nationwide settlement? with this Class Action?s lawsuit plaintiffs. Class Allegations In their complaint, the plaintiffs allege that:Model Year 2004 to 2010 BMW 5 Series E60 (Sedans) and Model Year 2006 to 2010 E61 (Sport Wagons) vehicles (""Preliminary Class Vehicles"") have defectively designed sunroofs drains which, if they become clogged, causes water intrusion and accumulation in the trunk/rear cabin well area of these vehicles. As a result, over time, this can potentially damage the electrical components and wiring that is located in the lowest part of the well area. Final Settlement Class Vehicles US specification Model Year 2007 to 2010 BMW 5 Series E60 (Sedans) and E61 (Sport Wagons) vehicles (""Final Settlement Class Vehicles"") registered and operated in the US (including Puerto Rico). Cass Members US residents (including Puerto Rico) who purchased or leased a Class Vehicle. Settlement Terms for Final Settlement Class Vehicles For eligible vehicles, the free inspection is available one-time (repair/claim dates) beginning on 8/28/2017 but no later than the extended date of 11/21/2018, Class Members will be permitted to bring their Class Vehicle to an authorized BMW center to have the free one-time inspection and control module relocation procedure performed. SI B01 28 17 (DC 54 12 90 01 00) CLASS ACTION LAWSUIT SETTLEMENT: WATER INTRUSION AND ACCUMULATION IN THE TRUNK (E60)/REAR CABIN WELL (E61) AREA, MAY APPLY. FOR ELIGIBLE VEHICLES, AN INSPECTION AND APPLICABLE CORRESPONDING REPAIRS ARE AVAILABLE ONE-TIME (REPAIR/CLAIM DATES) BEGINNING ON 8/28/2017 BUT NO LATER THAN THE EXTENDED DATE OF 11/21/2018. CLASS ACTION LAWSUIT SETTLEMENT: WATER INTRUSION AND ACCUMULATION IN THE TRUNK (E60)/REAR CABIN WELL (E61) AREA, SERVICE INFORMATION BULLETIN SI

Components: STRUCTURE:BODY:ROOF AND PILLARS. Confirm detailed applicability in the original document.